Chrysler Grand Voyager recalls

The driver�s airbag emblem may have become loose or detached.

Fix: Remove the emblem and the emblem retainers

2,939 vehicles · built 30 May 2006 to 9 Dec 2011

It has been identified that due to corrosion there maybe a malfunction of the power supply within the Occupant Restraint Control (ORC) module. This could result in either an illuminated airbag warning lamp with the possibility of no airbag deployment in a crash necessitating airbag deployment or an inadvertent airbag deployment without an illuminated airbag warning lamp. Either of these conditions could increase the risk of a crash or injury.

Fix: Recall all affected vehicle to replace the Occupant Restraint Control module.

1,296 vehicles · built 29 Jan 2007 to 31 Aug 2008

The ignition module may unintentionally move the key FOB to the accessory position whilst the vehicle is moving and shut off the engine.

Fix: On affected vehicles replace ignition module and key FOBs.

4,287 vehicles · built 29 Jan 2007 to 18 Jun 2010

If liquid water or moisture enters the rear quarter vent window switch it may cause the switch to overheat. This can result in a burning smell or smoke being emitted from the switch or in extreme circumstances it can cause a driver�s door fire.

Fix: Recall all affected vehicles to replace the rear quarter vent window switch and if required repair the electrical connector.

1 vehicle · built 1 Aug 2010 to 31 Oct 2014

The vehicle Weight Certification label has the incorrect value for Gross Vehicle Weight Ratings (GVWR). Over loading the vehicle is possible without understanding the correct GVWR specification which could cause a crash without warning.

Fix: Recall the vehicles that are likely to be affected and replace the Weight certification label.

481 vehicles · built 21 Aug 2013 to 26 Jun 2014

In the event of a collision from the B-pillar rearward the incorrect side airbags may deploy. This would create an increased risk of injury.

Fix: Recall the vehicles that are likely to be affected to reprogramme the Occupant Restraint Control (ORC) module.

208 vehicles · built 1 May 2012 to 30 Jun 2013

The Occupant Restraint Control (ORC) module may become contaminated by water leaking from the Heating venting & Air Conditioning (HVAC) drain grommet. This may lead to the illumination of the airbag warning light and the potential for an inadvertent airbag deployment without warning.

Fix: The repair is to replace the OCR module in addition to having the HVAC tube and grommet replaced

1,799 vehicles · built 1 Jan 2008 to 31 Dec 2008

It has been identified that the brake pads fitted to the front and rear of the vehicle during production do not comply with ECE 13 Regulation. In extreme cases this may affect the braking performance of the vehicle.

Fix: Recall all affected vehicles and replace the brake pads.

321 vehicles · built 1 May 2011 to 31 May 2011

Under certain conditions rough or uneven roads it is possible that the ignition switch may move to the 'Accessory' position whilst the vehicle is in motion. This can cause the engine stop and could result in a collision.

Fix: Recall all affected vehicles for inspection and the fitment of additional parts to overcome the issue.

539 vehicles · built 1 Jan 2007 to 30 Jun 2010

Because a rivet may be either missing or incorrectly installed in the steering column in the event of an impact the steering column performance could be compromised.

Fix: Recall the vehicles that are likely to be affected to check and where necessary install a missing rivet or replace an incorrectly installed rivet.

25 vehicles · built 15 Apr 2011 to 14 May 2011

It is possible that the wiring for the power Sliding Door can on the hinge mechanism during operation. This result in the latch mechanism overheating and lead to a possible fire or personal injury.

Fix: Recall all affected vehicles for the wiring to be checked repaired or replaced as necessary.

2,375 vehicles

The Heating Ventilation and Air-Conditioning (HVAC) drain tube and grommet may leak water onto the passenger compartment carpeting and/or the Occupant Restraint Control (OCR) module. This can lead to the illumination of the airbag warning lamp and the potential for an inadvertent airbag deployment without warning.

Fix: The HVAC drain tube and grommet must be replaced.

1,799 vehicles

After extended use the fuel rail crossover tube O rings may leak fuel. This may lead to an engine compartment fire.

Fix: Fit external seals at the fuel crossover points. If the joints are leaking or show signs of rust the fuel rail assembly will be replaced.

8,555 vehicles · built 1 Jan 1999 to 31 Dec 1999