Mercedes-Benz X-Class recalls

On affected vehicles due to a potential error in the press-fitting process during production�a leak at the radial shaft seals of the rear axle could occur and allow oil to enter the parking brake drum.

Fix: Replace the radial shaft sealing rings in the rear axle tube and parking brake shoes if contaminated

4,731 vehicles · built 27 Oct 2017 to 6 May 2020

On certain vehicles the glass of the canopy rear window could break.

Fix: As a precautionary measure install EPDM blocks (ethylene-propylene-diene rubber) in the rear section of the canopy for vehicles that were additionally equipped with a canopy.

4,738 vehicles · built 27 Oct 2017 to 6 May 2020

The return pipe of the oil cooler may chafe on the front axle cross member.

Fix: Measure the distance between the return line and the front axle cross member on the potentially affected vehicles and check the oil line for leaks and damage. If necessary the oil line will be replaced and the distance ensured with the aid of a new retainer.

1,546 vehicles · built 20 Aug 2017 to 15 May 2020

The child safety lock on the rear doors in combination with the �Super-Lock� function cannot always be ensured.

Fix: Install an additional grommet on the rear doors on the child safety lever on the affected vehicles.

1,128 vehicles · built 6 Nov 2017 to 5 Apr 2018

Leakage and subsequently a gradual loss of fluid from the hydraulic steering system.

Fix: Check the screw connection of the hydraulic steering line and ensure the correct tightening torque is applied. Top up fluid level if required.

4,535 vehicles · built 6 Nov 2017 to 29 Nov 2019

The additional function for the trailer stabilization (TSA) might not have been included as part of the retrofitting of trailer hitches.

Fix: Replace the ESP control unit on the affected vehicles to provide the TSA function.

30 vehicles · built 19 Feb 2018 to 2 Oct 2018

The operator�s manual does not indicate the correct maximum roof load values.

Fix: Replace the operator�s manuals and update software for the vehicle�s digital operating manual.

4,631 vehicles · built 6 Nov 2007 to 18 Feb 2020

Active Brake Assist system may mistakenly detect an obstacle where there is no obstacle

Fix: Update the software of the driver assistance systems control unit in the affected vehicle

4,089 vehicles · built 6 Nov 2017 to 31 May 2019

The maximum permissible roof load is not documented in the operating manual

Fix: The vehicle operating manuals are to be exchanged. For all vehicles with canopies installed the corresponding accessory operating manual will also be exchanged

3,546 vehicles · built 6 Nov 2017 to 19 Mar 2019

Incorrect specified tightening torque for the mounting screws of a cross member to be installed in conjunction with towbar fitment.

Fix: Mounting bolts on the trailer coupling are to be replaced if already fitted. Instructions to be updated on supplied kits.

2,324 vehicles · built 6 Nov 2017 to 18 Jan 2019

On affected vehicles the possibility exists that there may be a software error in the tyre pressure monitoring system of some X-Class vehicles If the tyre pressure falls below the minimum level required the intended warning message may not be shown in instrument cluster as a result of this error. Driving with tyre pressure that is too low causes increased and/or uneven tyre wear and changes the steering and braking behaviour of the vehicle. This may increase the risk of accident

Fix: As a precautionary measure recall the affected vehicles and perform a software check/update in the tyre pressure monitor control unit.

99 vehicles · built 9 Mar 2018 to 13 Mar 2018