Vauxhall Crossland X recalls

Vehicles may be affected by incorrect performance of the On-Board-Diagnostics related to Selective Catalytic Reduction system and/or Diesel Particle Filter. The Malfunction Indicator Light (MIL) may not illuminate in the event of a malfunction and therefore does not comply with emission regulations.

Fix: Update the Engine Control Unit software to ensure compliance to regulations.

9 vehicles · built 6 Oct 2017 to 5 Oct 2020

Vehicles may be affected by premature wearing of the camshaft drive chain leading to abnormal noise or to a breakage of the chain in the worst case.

Fix: Update the software to improve oil pressure and reduce wear. Check the engine noise and replace the chain if required. If no problem found change the oil to one with higher viscosity and special anti-wear additives.

3,035 vehicles · built 16 Jul 2019 to 31 Jan 2023

On affected vehicles below 12500 miles under certain conditions engine emissions may lead to a non-compliance to regulatory requirements.

Fix: Check the mileage of the vehicle and update the ECU (Engine Control Unit) calibration on vehicles below 12500 miles.

909 vehicles · built 3 Jan 2022 to 9 Nov 2022

Affected vehicles may have been fitted with a rear axle crossmember that was not manufactured according to specifications.

Fix: Check and replace the rear axle crossmember if necessary.

598 vehicles · built 26 May 2022 to 15 Jun 2022

Affected vehicles have Engine Control Unit software not according to specification.

Fix: Reprogramme the ECU (Engine Control Unit) with updated software.

20 vehicles · built 11 Jul 2017 to 20 Jul 2018

On the affected vehicles the operation of the brake vacuum pump may be affected by material detaching from the timing belt caused by the ageing of the engine oil.

Fix: To rectify this issue a software update will be downloaded which will improve the vacuum diagnosis (in order to warn earlier about the risk of loss or reduction of braking assistance).

10,100 vehicles · built 17 Jan 2017 to 12 Jul 2017

The passenger seatbelt warning chime might be inoperative.

Fix: Reprogram the Body Control Module software.

10,576 vehicles · built 17 Aug 2021 to 3 May 2022

Possible leaky connection on the high pressure fuel pump.

Fix: Re-tighten the high pressure fuel pump and replace the fuel supply pipe.

2 vehicles · built 21 May 2019 to 14 Feb 2020

The lambda control may not work sufficiently which may result in a NOx limit exceedance

Fix: A software calibration for the lambda control

6,282 vehicles · built 28 Jun 2018 to 22 Mar 2019

The rear end impact limiter might not have been installed in production.

Fix: Check if the rear end impact limiter is present and install one if required.

219 vehicles · built 10 Feb 2017 to 15 May 2017

The bolts securing the rear axle beam to the vehicle underbody could break.

Fix: Replace the rear axle affected bolts.

539 vehicles · built 15 Mar 2010 to 26 Mar 2018

on a certain number of Crossland X - Model Year 18 the Fastening Nut of the Rear Axle Hub might potentially become loose. This can lead to a separation of the rear wheel resulting in a loss of steering control.

Fix: Vauxhall Authorised Repairers are instructed to check both Rear Axle Hub Nuts for correct application of the securing punch if correct no further action. if incorrect replace hubstud and nut assembly

3 vehicles

The engine pistons may not be according to specification leading to oil entry in the inlet circuit. In a worst case this may cause an increased engine rpm for a few seconds possibly resulting in a total engine failure.

Fix: Perform a test of the engine to establish if the pistons are to specification. Where necessary the engine will be replaced.

52 vehicles · built 9 Oct 2017 to 1 Dec 2017