Vauxhall recalls

Affected vehicles may have Vehicle Supervision Module (VSM) software that displays incorrect speed-limit indications resulting in non-compliance with applicable regulatory requirements.

Fix: Update the VSM software and update the In-Vehicle-Infotainment software via Over-The-Air at the dealer if necessary.

269 vehicles · built 26 Sep 2025 to 10 Dec 2025

On affected vehicles a software defect in the instrument cluster may prevent the cluster display from switching on when the vehicle is started resulting in a black screen.

Fix: Update the Body Control Module software.

105 vehicles · built 12 Jun 2025 to 1 Mar 2026

On affected vehicles the Body Control Module is not correctly configured to detect a failure in the indicator lamps. As a result if a turn indicator bulb fails it's not detected and the indicator warning does not activate.

Fix: Update the vehicle configuration and the Secure Gateway Electronic Control Unit.

2,310 vehicles · built 1 Feb 2024 to 9 Jul 2025

Affected vehicles may experience an unexpected deactivation of the interior door handles when the key is in engine-running mode which could result in occupants being unable to exit.

Fix: Update the Vehicle Supervision Module software.

9,993 vehicles · built 11 Jul 2023 to 28 Feb 2025

Affected vehicles may experience an unexpected deactivation of the interior door handles when the key is in engine-running mode which could result in occupants being unable to exit.

Fix: Update the Vehicle Supervision Module software.

14,458 vehicles · built 13 Jun 2024 to 4 Jul 2025

Affected vehicles may have an incorrectly routed fuel pipe at risk of contact with other components which could lead to a fuel leak or risk of fire.

Fix: Check the correct routing of the fuel pipe and replace if necessary.

49 vehicles · built 17 Oct 2025 to 22 Jan 2026

Affected vehicles have a smart tachograph fitted that may not comply with regulatory requirements.

Fix: Replace the Tachograph Sensor Antenna(s) and adding Wiring Harnesses if necessary.

87 vehicles · built 27 Sep 2024 to 4 Dec 2025

Due to a mechanical failure in the reducer bearing combined with a specific defect in the Electric Power Steering (EPS) software calibration affected vehicles may experience a loss of power steering which in the worst case could lead to steering lock.

Fix: Update the EPS software calibration to prevent the potential loss of steering assistance.

225 vehicles · built 15 May 2023 to 8 Sep 2023

On affected vehicles the Lane Keep Assist tell-tale fails to illuminate if the front camera is blocked meaning no warning light appears in the instrument cluster.

Fix: Update the Body Control Module software.

16,348 vehicles · built 11 Apr 2024 to 9 Apr 2025

On affected vehicles the Lane Keep Assist tell-tale fails to illuminate if the front camera is blocked meaning no warning light appears in the instrument cluster.

Fix: Update the Body Control Module software.

2,720 vehicles · built 15 Apr 2024 to 9 Apr 2025

On certain Vauxhall Astra L vehicles the Automatic Emergency Braking Assist telltale fails to illuminate if the front camera is blocked. No AEB warning telltale meaning no warning light appears in the instrument cluster. An additional pop-up appears for around 10 seconds at each key on/key off (Driving Assistance Sensor Blind: clean sensor see User Manual). The Automatic Emergency Braking system is operating in a degraded mode but remains functional due to radar support.

Fix: To rectify this issue we will update the Vehicle System Management software

3,270 vehicles · built 4 Jan 2023 to 10 Apr 2025

On affected vehicles due to a production nonconformity the water pump may malfunction which may cause a loss of engine power and result in the engine shutting down.

Fix: Replace the water pump.

1,587 vehicles · built 15 Oct 2025 to 18 Feb 2026

On affected vehicles due to a production nonconformity the water pump may malfunction which may cause a loss of engine power and result in the engine shutting down.

Fix: Replace the water pump.

2,064 vehicles · built 15 Oct 2025 to 28 Feb 2026

Affected vehicles may have been assembled with contact or with a reduced clearance between the Gasoline Particulate Filter pipe and the pole protection cap of the 48V Belt Starter Generator. There is a possibility of contact between these components leading to water infiltration and an electrical arch which could trigger a thermal event.

Fix: Replace the pole protection cap of the 48V Belt Starter Generator. Check the distance between the Gasoline Particulate Filter pipe and the pole protection cap of the 48V Belt Starter Generator and re‑position or replace the pipe if required.

1,888 vehicles · built 1 Jun 2023 to 13 Jan 2026

Affected vehicles may have been assembled with contact or with a reduced clearance between the Gasoline Particulate Filter pipe and the pole protection cap of the 48V Belt Starter Generator. There is a possibility of contact between these components leading to water infiltration and an electrical arch which could trigger a thermal event.

Fix: Replace the pole protection cap of the 48V Belt Starter Generator. Check the distance between the Gasoline Particulate Filter pipe and the pole protection cap of the 48V Belt Starter Generator and re‑position or replace the pipe if required.

534 vehicles · built 5 Feb 2024 to 13 Jan 2026

Affected vehicles may have been assembled with contact or with a reduced clearance between the Gasoline Particulate Filter pipe and the pole protection cap of the 48V Belt Starter Generator. There is a possibility of contact between these components leading to water infiltration and an electrical arch which could trigger a thermal event.

Fix: Replace the pole protection cap of the 48V Belt Starter Generator. Check the distance between the Gasoline Particulate Filter pipe and the pole protection cap of the 48V Belt Starter Generator and re‑position or replace the pipe if required.

2,057 vehicles · built 30 Jul 2024 to 22 Dec 2025

On affected vehicles the front camera module calibration may be incorrect which may lead to non-compliance with the speed limit indication system regulatory requirement.

Fix: Update the central vehicle management software.

101 vehicles · built 7 Jan 2025 to 23 Oct 2025

Affected vehicles may have been fitted with fuel return pipes not according to specification which can lead to a fuel leak.

Fix: Check the fuel return pipes and replace if necessary.

560 vehicles · built 6 Nov 2024 to 23 Jul 2025

On affected vehicles a non-conformity issue with the fuel injection common rail may lead to a loosening of the nut and a potential fuel leak.

Fix: Check the fuel injection common rail and if necessary replace the rail and high-pressure fuel pipes.

79 vehicles · built 26 Jul 2025 to 8 Oct 2025

On affected vehicles a non-conformity issue with the fuel injection common rail may lead to a loosening of the nut and a potential fuel leak.

Fix: Check the fuel injection common rail and if necessary replace the rail and high-pressure fuel pipes.

419 vehicles · built 25 Jul 2025 to 10 Oct 2025

On affected vehicles the incorrect wheel bolts may have been fitted which could result in loosening or loss of the bolts.

Fix: Check the correct bolts are fitted and replace if necessary.

95 vehicles · built 29 Sep 2023 to 23 Sep 2025

Affected vehicle may face a black screen on the Instrument Panel Cluster with several functions not available to view.

Fix: Update the In-Vehicle-Infotainment software via Over-the-Air.

9,008 vehicles · built 11 Oct 2023 to 3 Jul 2025

Affected vehicle may face a black screen on the Instrument Panel Cluster with several functions not available to view.

Fix: Update the In-Vehicle-Infotainment software via Over-the-Air.

4,066 vehicles · built 11 Oct 2023 to 3 Jul 2025

Affected vehicles may have the Headlamp Height Level sensor fitted with incorrect orientation causing the Headlamp beam to be aimed too low and does not adjust as it should.

Fix: Check the Height Level Sensor for correct assembly and replace if necessary.

698 vehicles · built 20 Nov 2023 to 24 Mar 2025

On affected vehicles the chemicals in the Takata airbag inflators may deteriorate over time. This may cause the inflators to rupture with too much force in a crash leading to serious injury or death in a worst-case scenario.

Fix: Replace the driver airbag module.

231,159 vehicles · built 3 Jan 2005 to 11 Jun 2014

On affected vehicles the chemicals in the Takata airbag inflators may deteriorate over time. This may cause the inflators to rupture with too much force in a crash leading to serious injury or death in a worst-case scenario.

Fix: Replace the driver airbag module.

174,846 vehicles · built 15 Dec 2011 to 6 Jun 2018

On affected vehicles the chemicals in the Takata airbag inflators may deteriorate over time. This may cause the inflators to rupture with too much force in a crash leading to serious injury or death in a worst-case scenario.

Fix: Replace the driver airbag module.

357,346 vehicles · built 24 Feb 2009 to 23 Aug 2018

On affected vehicles the chemicals in the Takata airbag inflators may deteriorate over time. This may cause the inflators to rupture with too much force in a crash leading to serious injury or death in a worst-case scenario.

Fix: Replace the driver airbag module.

2,990 vehicles · built 8 May 2012 to 22 Aug 2018

On affected vehicles the chemicals in the Takata airbag inflators may deteriorate over time. This may cause the inflators to rupture with too much force in a crash leading to serious injury or death in a worst-case scenario.

Fix: Replace the driver airbag module.

76,875 vehicles · built 5 Feb 2009 to 24 Mar 2017

On affected vehicles the chemicals in the Takata airbag inflators may deteriorate over time. This may cause the inflators to rupture with too much force in a crash leading to serious injury or death in a worst-case scenario.

Fix: Replace the driver airbag module.

333 vehicles · built 16 Feb 2005 to 19 Jun 2008

On affected vehicles the chemicals in the Takata airbag inflators may deteriorate over time. This may cause the inflators to rupture with too much force in a crash leading to serious injury or death in a worst-case scenario.

Fix: Replace the driver airbag module.

54,365 vehicles · built 4 Jul 2003 to 10 Oct 2008

On affected vehicles the chemicals in the Takata airbag inflators may deteriorate over time. This may cause the inflators to rupture with too much force in a crash leading to serious injury or death in a worst-case scenario.

Fix: Replace the driver airbag module.

51,422 vehicles · built 25 Feb 2011 to 26 Jul 2016

On affected vehicles the front left and right control arm ball-joint bracket screws are at risk of fracture which could affect the vehicle's controllability.

Fix: Inspect the marking on the left and right front ball-joint bracket and change if necessary.

6,448 vehicles · built 8 May 2024 to 27 Feb 2025

On affected vehicles there may be an insufficient brake pedal bracket connection due to a missing or incorrectly assembled pin. If the pin falls out the brake pedal will potentially disengage.

Fix: Check the brake pedal connection confirm proper assembly and rework it if necessary.

2,380 vehicles · built 3 Sep 2025 to 2 Nov 2025

On affected vehicles there is an issue with the Engine Control Module (ECM) calibration which may lead to non-compliance with regulatory emission requirements.

Fix: Update the ECM calibration.

4,104 vehicles · built 2 May 2022 to 29 Jan 2024

Affected vehicles may have incorrect or missing tyre pressure messages displayed in the instrument cluster due to a software deviation.

Fix: Update the Electric Stability Control calibration to ensure the correct tyre pressure warning messages are displayed

3,067 vehicles · built 17 Jan 2025 to 27 Jun 2025

Affected vehicles may have incorrect or missing tyre pressure messages displayed in the instrument cluster due to a software deviation.

Fix: Update the Electric Stability Control calibration to ensure the correct tyre pressure warning messages are displayed

692 vehicles · built 28 Oct 2023 to 7 Mar 2024

Affected vehicles may have incorrect or missing tyre pressure messages displayed in the instrument cluster due to a software deviation.

Fix: Update the Electric Stability Control calibration to ensure the correct tyre pressure warning messages are displayed

5,400 vehicles · built 4 Mar 2025 to 27 Jun 2025

Affected vehicles may have been equipped with rear brake discs out of specification. These brake discs have insufficient contact with the wheel hub resulting in abnormal stress concentration.

Fix: Check the rear brake discs and replace them and the brake pads if necessary.

5 vehicles · built 24 Jan 2024 to 24 Jan 2024

On affected vehicles the engine will run all the time and will not shut off in start/stop mode due to incorrect Body Control Module coding.

Fix: Update the Body Control Module software.

7,659 vehicles · built 11 Sep 2024 to 7 May 2025

On affected vehicles the engine will run all the time and will not shut off in start/stop mode due to incorrect Body Control Module coding.

Fix: Update the Body Control Module software.

6,381 vehicles · built 5 Feb 2024 to 13 Nov 2024

Affected vehicles may have an incorrect speed limitation value displayed on the instrument cluster due to a wrong configuration.

Fix: Update the configuration in the body control module.

48 vehicles · built 5 Dec 2024 to 22 Feb 2025

We would like to update the Engine Control Module software as it may have an incorrect version in order to avoid higher CO2 values than those stated in the CoC and thus to comply to emission regulatory requirements.

Fix: Update the Engine Control Module software

4 vehicles · built 29 Nov 2024 to 4 Dec 2024

Affected vehicles may have a fault in the High Voltage Battery which could potentially lead to it overheating and in the worst case a battery or vehicle fire. Customers are advised to stop any plug-in charging and eSave charging until the vehicle is reworked.

Fix: Update the battery management software or replace the High Voltage Battery if necessary.

1,038 vehicles · built 2 Jul 2019 to 19 Aug 2021

On affected vehicles there is a risk of the brake bar welding breaking leading to a complete loss of braking.

Fix: Currently there is no determined remedy. You are advised not to drive the vehicle. The repairer will arrange a replacement mobility solution.

353 vehicles · built 10 Jun 2025 to 2 Aug 2025

Affected vehicles have been fitted with the wrong Autonomous Telematic Box. This means it cannot connect to the remoter server making it impossible to make E-Calls or use Intelligent Speed Assistance.

Fix: Replace the Autonomous Telematic Box.

2 vehicles · built 10 Dec 2024 to 20 Feb 2025

On affected vehicles the Automatic Emergency Brake (AEB) function may remain deactivated in a specific use case.

Fix: Update the Front Camera software to ensure correct activation / deactivation of the AEB system.

610 vehicles · built 8 Oct 2024 to 11 Mar 2025

Vehicles may be affected by incorrect performance of the On-Board-Diagnostics related to Selective Catalytic Reduction system and/or Diesel Particle Filter. The Malfunction Indicator Light (MIL) may not illuminate in the event of a malfunction and therefore does not comply with emission regulations.

Fix: Update the Engine Control Unit software to ensure compliance to regulations.

582 vehicles · built 14 Nov 2017 to 13 Dec 2021

Vehicles may be affected by incorrect performance of the On-Board-Diagnostics related to Selective Catalytic Reduction system and/or Diesel Particle Filter. The Malfunction Indicator Light (MIL) may not illuminate in the event of a malfunction and therefore does not comply with emission regulations.

Fix: Update the Engine Control Unit software to ensure compliance to regulations.

11 vehicles · built 16 Jul 2019 to 19 Oct 2020

Vehicles may be affected by incorrect performance of the On-Board-Diagnostics related to Selective Catalytic Reduction system and/or Diesel Particle Filter. The Malfunction Indicator Light (MIL) may not illuminate in the event of a malfunction and therefore does not comply with emission regulations.

Fix: Update the Engine Control Unit software to ensure compliance to regulations.

9 vehicles · built 6 Oct 2017 to 5 Oct 2020

Vehicles may be affected by incorrect performance of the On-Board-Diagnostics related to Selective Catalytic Reduction system and/or Diesel Particle Filter. The Malfunction Indicator Light (MIL) may not illuminate in the event of a malfunction and therefore does not comply with emission regulations.

Fix: Update the Engine Control Unit software to ensure compliance to regulations.

472 vehicles · built 18 Sep 2017 to 3 Dec 2020

Vehicles may be affected by incorrect performance of the On-Board-Diagnostics related to Selective Catalytic Reduction system and/or Diesel Particle Filter. The Malfunction Indicator Light (MIL) may not illuminate in the event of a malfunction and therefore does not comply with emission regulations.

Fix: Update the Engine Control Unit software to ensure compliance to regulations.

7,212 vehicles · built 16 Sep 2021 to 19 Oct 2023

Vehicles may be affected by incorrect performance of the On-Board-Diagnostics related to Selective Catalytic Reduction system and/or Diesel Particle Filter. The Malfunction Indicator Light (MIL) may not illuminate in the event of a malfunction and therefore does not comply with emission regulations.

Fix: Update the Engine Control Unit software to ensure compliance to regulations.

10,083 vehicles · built 14 May 2019 to 11 Oct 2021

On affected vehicles the bolts on the front wishbone may break due to corrosion.

Fix: Replace the bolts and bushings on both sides of the front wishbone.

29,927 vehicles · built 23 Sep 2020 to 30 Jun 2022

Affected vehicles may have incorrect or missing information on the tyre pressure label.

Fix: Replace the tyre pressure label.

773 vehicles · built 10 Nov 2023 to 13 Mar 2025

On affected vehicles there there may be loose connections between a high-pressure fuel pipe and the engine fuel rail which potentially could lead to a leak and risk of fire.

Fix: Retighten the affected connections.

112 vehicles · built 2 Jan 2024 to 23 Apr 2025

On affected vehicles there there may be loose connections between a high-pressure fuel pipe and the engine fuel rail which potentially could lead to a leak and risk of fire.

Fix: Retighten the affected connections.

1,106 vehicles · built 21 Feb 2023 to 22 Apr 2025

On affected vehicles there there may be loose connections between a high-pressure fuel pipe and the engine fuel rail which potentially could lead to a leak and risk of fire.

Fix: Retighten the affected connections.

23,792 vehicles · built 4 Nov 2022 to 17 Apr 2025

On affected vehicles there there may be loose connections between a high-pressure fuel pipe and the engine fuel rail which potentially could lead to a leak and risk of fire.

Fix: Retighten the affected connections.

7,647 vehicles · built 4 Feb 2023 to 24 Apr 2025

Vehicles may be affected by premature wearing of the camshaft drive chain leading to abnormal noise or to a breakage of the chain in the worst case.

Fix: Update the software to improve oil pressure and reduce wear. Check the engine noise and replace the chain if required. If no problem found change the oil to one with higher viscosity and special anti-wear additives.

11,585 vehicles · built 13 Oct 2017 to 31 Jan 2023

Vehicles may be affected by premature wearing of the camshaft drive chain leading to abnormal noise or to a breakage of the chain in the worst case.

Fix: Update the software to improve oil pressure and reduce wear. Check the engine noise and replace the chain if required. If no problem found change the oil to one with higher viscosity and special anti-wear additives.

1,525 vehicles · built 16 Jul 2019 to 31 Jan 2023

Vehicles may be affected by premature wearing of the camshaft drive chain leading to abnormal noise or to a breakage of the chain in the worst case.

Fix: Update the software to improve oil pressure and reduce wear. Check the engine noise and replace the chain if required. If no problem found change the oil to one with higher viscosity and special anti-wear additives.

32,012 vehicles · built 14 Nov 2020 to 31 Jan 2023

Vehicles may be affected by premature wearing of the camshaft drive chain leading to abnormal noise or to a breakage of the chain in the worst case.

Fix: Update the software to improve oil pressure and reduce wear. Check the engine noise and replace the chain if required. If no problem found change the oil to one with higher viscosity and special anti-wear additives.

3,035 vehicles · built 16 Jul 2019 to 31 Jan 2023

Vehicles may be affected by premature wearing of the camshaft drive chain leading to abnormal noise or to a breakage of the chain in the worst case.

Fix: Update the software to improve oil pressure and reduce wear. Check the engine noise and replace the chain if required. If no problem found change the oil to one with higher viscosity and special anti-wear additives.

649 vehicles · built 18 Jan 2018 to 3 May 2022

Vehicles may be affected by premature wearing of the camshaft drive chain leading to abnormal noise or to a breakage of the chain in the worst case.

Fix: Update the software to improve oil pressure and reduce wear. Check the engine noise and replace the chain if required. If no problem found change the oil to one with higher viscosity and special anti-wear additives.

7 vehicles · built 29 Jul 2021 to 31 Jan 2023

Vehicles may be affected by premature wearing of the camshaft drive chain leading to abnormal noise or to a breakage of the chain in the worst case.

Fix: Update the software to improve oil pressure and reduce wear. Check the engine noise and replace the chain if required. If no problem found change the oil to one with higher viscosity and special anti-wear additives.

247 vehicles · built 3 Feb 2021 to 30 Jan 2023

On affected vehicles the Autonomous Telematics Box (ATB) has no connectivity to the Connected Services features and therefore does not comply with regulatory requirements.

Fix: Replace the ATB to ensure compliance with regulatory requirements.

3 vehicles · built 24 May 2024 to 27 Aug 2024

On affected vehicles the Autonomous Telematics Box (ATB) has no connectivity to the Connected Services features and therefore does not comply with regulatory requirements.

Fix: Replace the ATB to ensure compliance with regulatory requirements.

1 vehicles · built 24 May 2024 to 7 Jun 2024

On affected vehicles a low AdBlue level message may not be displayed on the Instrument Panel Cluster. This could lead to the possibility of not being able to start the vehicle due to an empty AdBlue tank.

Fix: Update the Instrument Panel Cluster software.

6 vehicles · built 14 Oct 2021 to 18 Oct 2023

On affected vehicles the Electronic Brake System Module is not according to specification which could potentially lead to light internal leakage of brake fluid.

Fix: Replace the Electronic Brake System Module.

5 vehicles · built 24 May 2024 to 27 Aug 2024

On affected vehicles the Electronic Brake System Module is not according to specification which could potentially lead to light internal leakage of brake fluid.

Fix: Replace the Electronic Brake System Module.

37 vehicles · built 24 May 2024 to 7 Jun 2024

On affected vehicles the low-pressure fuel pipe could come in to contact with one of the ignition coil screws. This could lead to fuel pipe damage over time resulting in a fuel leak.

Fix: Fix the low-pressure fuel pipe to the crankcase breather hose with a cable tie to ensure there is no contact between the ignition coil screw and the fuel pipe.

1 vehicles · built 7 Oct 2024 to 10 Dec 2024

Affected vehicles may face an error in the Battery Monitoring Unit software.

Fix: Update the Battery Monitoring Unit software.

348 vehicles · built 13 Sep 2022 to 29 Nov 2022

Affected vehicles may face an error in the Battery Monitoring Unit software.

Fix: Update the Battery Monitoring Unit software.

864 vehicles · built 30 Aug 2022 to 7 Dec 2022

Affected vehicles may face an error in the Battery Monitoring Unit software.

Fix: Update the Battery Monitoring Unit software.

1,303 vehicles · built 1 Jun 2022 to 30 Nov 2022

Affected vehicles may face an error in the Battery Monitoring Unit software.

Fix: Update the Battery Monitoring Unit software.

559 vehicles · built 13 Jul 2022 to 2 Mar 2023

Affected vehicles may have been equipped with an Autonomous Telematic Box (ATB) which does not work.

Fix: Change the ATB.

4 vehicles · built 15 Apr 2024 to 7 Jul 2024

Affected vehicles may have been equipped with an Autonomous Telematic Box (ATB) which does not work.

Fix: Change the ATB.

62 vehicles · built 15 May 2024 to 14 Sep 2024

On affected vehicles the engine is at risk of becoming damaged because of an inadequate oil supply from an oil jet cooling nozzle.

Fix: Replace the engine oil and filter.

26,315 vehicles · built 6 Oct 2022 to 4 Apr 2024

Affected vehicles may experience an autonomous telematic box that cannot connect to the remote server making it not possible to make calls or use other connected services.

Fix: Disconnect the 12V battery and reconnect it after 15 seconds then check for a trouble code.

62 vehicles · built 9 Apr 2024 to 8 Nov 2024

Affected vehicles may experience an autonomous telematic box that cannot connect to the remote server making it not possible to make calls or use other connected services.

Fix: Disconnect the 12V battery and reconnect it after 15 seconds then check for a trouble code.

18 vehicles · built 5 Mar 2024 to 1 Jun 2024

Affected vehicles may experience an autonomous telematic box that cannot connect to the remote server making it not possible to make calls or use other connected services.

Fix: Disconnect the 12V battery and reconnect it after 15 seconds then check for a trouble code.

135 vehicles · built 19 Feb 2024 to 5 Dec 2024

Affected vehicles may face potential leakage of the under-bonnet fuel pipe due to a weakness of its crimping.

Fix: Change the fuel pipe.

12 vehicles · built 2 Jan 2024 to 13 Sep 2024

Affected vehicles may face potential leakage of the under-bonnet fuel pipe due to a weakness of its crimping.

Fix: Change the fuel pipe.

36 vehicles · built 4 Feb 2024 to 14 Sep 2024

On affected vehicles the wiring harness for both front seats may be routed incorrectly which may lead to a short circuit and the potential risk of a non-working airbag.

Fix: Check and if necessary re-route the wiring harness.

1,141 vehicles · built 21 Mar 2024 to 19 Nov 2024

Affected vehicles may not comply with test requirements in the matter of emissions test execution by competent authorities and energy consumption may be too high.

Fix: Update the electrical Vehicle Control Unit (eVCU) software.

583 vehicles · built 19 Jan 2023 to 13 Mar 2024

Affected vehicles may not comply with test requirements in the matter of emissions test execution by competent authorities and energy consumption may be too high.

Fix: Update the electrical Vehicle Control Unit (eVCU) software.

232 vehicles · built 4 Jul 2023 to 8 Mar 2024

Affected vehicles may not comply with test requirements in the matter of emissions test execution by competent authorities and energy consumption may be too high.

Fix: Update the electrical Vehicle Control Unit (eVCU) software.

43 vehicles · built 6 Sep 2023 to 15 Feb 2024

On affected vehicles the traffic sign recognition function does not meet regulatory requirements. After de-activation it will remain de-activated even after vehicle restart.

Fix: Update the radio software via over-the-Air.

77 vehicles · built 7 Dec 2023 to 25 May 2024

On affected vehicles the front tyres may have been damaged in the production process.

Fix: Check the front tyres and change if necessary.

522 vehicles · built 9 Oct 2024 to 22 Oct 2024

On affected vehicles the fixing bolts on the front left or right bracket on the lower control arm may break. In the worst-case scenario 2 broken bolts could affect the controllability of the vehicle.

Fix: Change the front left and right ball joint brackets.

2,361 vehicles · built 21 Mar 2024 to 4 Dec 2024

On affected vehicles the Advanced Driver Assistance System (ADAS) functionality may not meet regulatory requirements and the Active Emergency Brake (AEB) and Lane Keep Assist (LKA) can inadvertently be deactivated by a long press of the ADAS button on the radio.

Fix: On the affected vehicles the radio software will be updated by an Over-The-Air update which will be remotely checked as successfully installed.

2,582 vehicles · built 1 Jun 2023 to 3 May 2024

On affected vehicles the fuel pipe may chafe as a result of being in contact with the engine harness.

Fix: On the affected vehicles check the fuel pipe and if necessary replace the pipe in addition a spacer will be fitted to avoid any risk of chafing.

2,803 vehicles · built 25 Apr 2014 to 21 Dec 2021

On affected vehicles they may have been supplied with incorrect software in the Traction Battery Management Unit TBMU that can lead to a non-compliance with regulatory requirements.

Fix: On the affected vehicles the TBMU software will be updated to meet regulatory requirements.

30 vehicles · built 22 Aug 2024 to 24 Sep 2024

On affected vehicles there may be insufficient fixing on the 1st and/or 2nd row of seats that could potentially allow seat movement in the event of a collision

Fix: On the affected vehicles seat fixings will be reworked

2,503 vehicles · built 28 Aug 2024 to 8 Oct 2024

On affected vehicles the radio display fixing screws may be missing allowing a potential detachment of the display during a collision.

Fix: On the affected vehicles the fixings will be checked and fitted if necessary.

7,931 vehicles · built 8 Mar 2024 to 4 Oct 2024

On affected vehicles the passenger front airbag may not deploy properly in the event of a collision.

Fix: On affected vehicles the passenger front air bag will be replaced.

122 vehicles · built 28 Apr 2009 to 19 May 2009

On affected vehicles the steering rack fitted may not conform to specification and result in an increased force to rotate the steering wheel.

Fix: On the affected vehicles the steering rack will be replaced.

562 vehicles · built 9 Apr 2024 to 18 May 2024

Affected vehicles may have been equipped with the incorrect rear springs which can result in impaired driving behaviour when fully loaded or a risk of rear spring detachment in a worst-case scenario when empty.

Fix: Replace both rear springs.

1,230 vehicles · built 10 Jan 2024 to 28 Jun 2024

Affected vehicles may exceed regulatory emission standards

Fix: Replace the canister purge valve (CPV) and or fuel line.

53,853 vehicles · built 15 Jul 2019 to 26 Jan 2023

On affected vehicles there is a fault in the High Voltage (HV) Battery which could potentially lead to a breakdown charging issue and/or overheating and in a worst-case scenario a High Voltage Battery or vehicle fire.

Fix: Replace the High Voltage Battery.

264 vehicles · built 3 May 2023 to 25 May 2023

On affected vehicles equipped with E-call the device may not function when trying to connect to E-Call (Emergency Call) and B-Call (Breakdown Call) due to incorrect BSRF (On-board radiocommunication transmitter) configuration and as a result does not comply with regulatory requirements.

Fix: Check and replace the Radio frequency connectivity box.

4 vehicles · built 3 May 2023 to 25 May 2023

On affected vehicles there could be a loss of ground connections for some electrical harnesses which could result in a worst-case scenario in the loss of several vehicle functions with safety impacts and a risk of erratic behaviour of the vehicle.

Fix: Check and re-tighten the ground connections.

24 vehicles · built 15 Apr 2023 to 17 Jan 2024

On affected vehicles incorrect MCU (Motor Control Unit) calibration may result in a loss of propulsion while driving.

Fix: Update the MCU (Motor Control Unit) calibration

265 vehicles · built 11 Dec 2023 to 21 Feb 2024

On affected vehicles below 12500 miles under certain conditions engine emissions may lead to a non-compliance to regulatory requirements.

Fix: Check the mileage of the vehicle and update the ECU (Engine Control Unit) calibration on vehicles below 12500 miles.

347 vehicles · built 11 Jan 2022 to 6 Dec 2023

On affected vehicles below 12500 miles under certain conditions engine emissions may lead to a non-compliance to regulatory requirements.

Fix: Check the mileage of the vehicle and update the ECU (Engine Control Unit) calibration on vehicles below 12500 miles.

376 vehicles · built 5 Jan 2022 to 19 Oct 2022

On affected vehicles below 12500 miles under certain conditions engine emissions may lead to a non-compliance to regulatory requirements.

Fix: Check the mileage of the vehicle and update the ECU (Engine Control Unit) calibration on vehicles below 12500 miles.

909 vehicles · built 3 Jan 2022 to 9 Nov 2022

On affected vehicles below 12500 miles under certain conditions engine emissions may lead to a non-compliance to regulatory requirements.

Fix: Check the mileage of the vehicle and update the ECU (Engine Control Unit) calibration on vehicles below 12500 miles.

229 vehicles · built 4 Jan 2022 to 10 Jan 2023

Affected vehicles may have been built with a rear axle not properly welded.

Fix: Check the rear axle assembly and replace it if necessary.

Vehicle count not given · built 13 Jan 2023 to 18 Jan 2023

Affected vehicles may have been built with a rear axle not properly welded.

Fix: Check the rear axle assembly and replace it if necessary.

74 vehicles · built 13 Jan 2023 to 18 Jan 2023

On affected vehicles a defective 4x4 transfer box oil seal might leak resulting in the rear wheels locking up and a loss of control of the vehicle.

Fix: Remove and replace the front transfer box oil seal.

1 vehicles · built 1 Apr 2019 to 1 Dec 2019

On affected vehicles the Adaptive Cruise Control (ACC) may not be able to be activated. In the worst case this can lead to unintentional self-braking due to premature activation of the Automatic Emergency Braking (AEB) without there being anything in front of the vehicle. This is due to a metal sticker stuck in front of the radar module.�

Fix: Check for the sticker in the radar zone and remove it if necessary.

506 vehicles · built 10 May 2022 to 21 May 2022

On affected vehicles the hydraulic power steering hose is not according to specification which could lead to deterioration in power steering assistance or sudden loss of steering assistance.�

Fix: Check and replace power steering hose if necessary.�

786 vehicles · built 20 Mar 2023 to 12 Sep 2023

Affected vehicles may have a too low torque on the wheel bolts that could lead to loose wheels or wheel detachment in a worst case scenario.

Fix: Check and re-torque wheel bolts if necessary.

108 vehicles · built 28 Jul 2023 to 19 Sep 2023

On affected vehicles due to a potential lack of electric parking brake application when the driver presses the throttle pedal to start driving from a parking position on a slope the vehicle could move in the opposite direction until the driver pushes the brakes and stops the vehicle.

Fix: Update the MCU (Motor Control Unit) with modified software.

349 vehicles · built 6 Mar 2023 to 29 Aug 2023

Affected vehicles may have been fitted with a rear axle crossmember that was not manufactured according to specifications.

Fix: Check and replace the rear axle crossmember if necessary.

598 vehicles · built 26 May 2022 to 15 Jun 2022

Affected vehicles may have a tyre load index reported on the vehicle�s CoC lower than the rear axle capacity declared on the VIN label.

Fix: Replace the VIN label and provide an Addendum to the CoC (Certificate of Conformity).

2 vehicles · built 3 Oct 2022 to 15 Mar 2023

A front seatbelt pre-tensioner may malfunction which can cause the driver seatbelt pretensioner not to be activated when the passenger airbag is locked.

Fix: Check and replace the seatbelt pretensioner

1 vehicles · built 23 Apr 2022 to 17 May 2022

Affected vehicles have Engine Control Unit software not according to specification.

Fix: Reprogramme the ECU (Engine Control Unit) with updated software.

20 vehicles · built 11 Jul 2017 to 20 Jul 2018

Affected vehicles may not conform to regulatory emission requirements EU R83.

Fix: Reprogram ECU with updated software and calibration.

1,081 vehicles · built 7 Mar 2019 to 9 Oct 2020

Affected vehicles may be equipped with a B-Pillar manufacturer label with incorrect weight data which can lead to a non-conformity to regulatory requirements.

Fix: Replace the manufacturer label with one that has correct load values.

6,506 vehicles · built 12 Jun 2019 to 20 Feb 2020

On affected vehicles the AC compressor stator wiring could develop a fault leading to current loss inside the AC compressor that could result in a vehicle powertrain shutdown when driving.

Fix: Reprogram the Powertrain Diagnosis ECU with updated software.

34,528 vehicles · built 16 Oct 2019 to 4 Nov 2022

On affected vehicles the AC compressor stator wiring could develop a fault leading to current loss inside the AC compressor that could result in a vehicle powertrain shutdown when driving.

Fix: Reprogram the Powertrain Diagnosis ECU with updated software.

34,528 vehicles · built 27 Feb 2020 to 7 Dec 2022

On affected vehicles the AC compressor stator wiring could develop a fault leading to current loss inside the AC compressor that could result in a vehicle powertrain shutdown when driving.

Fix: Reprogram the Powertrain Diagnosis ECU with updated software.

34,528 vehicles · built 23 Mar 2021 to 19 Nov 2022

On affected vehicles the AC compressor stator wiring could develop a fault leading to current loss inside the AC compressor that could result in a vehicle powertrain shutdown when driving.

Fix: Reprogram the Powertrain Diagnosis ECU with updated software.

34,528 vehicles · built 28 Sep 2020 to 28 Oct 2020

A fuel pipe could develop a leak in the engine compartment which could lead to a risk of a vehicle fire.

Fix: Check and replace the fuel pipe if necessary.

235 vehicles · built 9 May 2022 to 22 Mar 2023

Affected vehicles may face the risk of perforation of the HV battery reinforcing plate/battery cover over the vehicle lifetime due to water intrusion.

Fix: A protective wax will be applied between HV battery reinforcing plate and battery cover.

1,375 vehicles · built 2 Jul 2019 to 27 Jan 2023

Affected vehicles may experience HV Battery overheating that may lead to a HV Battery thermal runaway and in a worst case to a battery or vehicle fire.

Fix: The BMS (Battery Management System) will be reprogrammed with enhanced battery monitoring software.

873 vehicles · built 2 Jul 2019 to 9 Dec 2022

Affected vehicles may experience HV Battery overheating that may lead to a HV Battery thermal runaway and in a worst case to a battery or vehicle fire.

Fix: The BMS (Battery Management System) will be reprogrammed with enhanced battery monitoring software.

770 vehicles · built 2 Jul 2019 to 9 Dec 2022

Affected vehicles may experience HV Battery overheating that may lead to a HV Battery thermal runaway and in a worst case to a battery or vehicle fire.

Fix: The BMS (Battery Management System) will be reprogrammed with enhanced battery monitoring software.

550 vehicles · built 2 Jul 2019 to 9 Dec 2022

Affected vehicles may have a steering tie rod/track rod end nut that has not been tightened to the correct torque.

Fix: Replace the steering tie rod/track rod end nut and tighten to the correct torque.

6 vehicles · built 1 Sep 2022 to 13 Dec 2022

Suspension wishbone bolts may have been incorrectly tightened during the production process.

Fix: Check and tighten wishbone bolts to the correct torque.

1,082 vehicles · built 22 Jul 2022 to 30 Nov 2022

There is an error in the software calibration of the traction battery control unit which could result in a loss of propulsion when driving.

Fix: Update the software of the traction battery control unit.

3,666 vehicles · built 30 May 2022 to 6 Dec 2022

There is an error in the software calibration of the traction battery control unit which could result in a loss of propulsion when driving.

Fix: Update the software of the traction battery control unit.

3,666 vehicles · built 5 Sep 2022 to 1 Dec 2022

There is an error in the software calibration of the traction battery control unit which could result in a loss of propulsion when driving.

Fix: Update the software of the traction battery control unit.

3,666 vehicles · built 17 Aug 2022 to 7 Dec 2022

On the affected vehicles the operation of the brake vacuum pump may be affected by material detaching from the timing belt caused by the ageing of the engine oil.

Fix: To rectify this issue a software update will be downloaded which will improve the vacuum diagnosis (in order to warn earlier about the risk of loss or reduction of braking assistance).

10,100 vehicles · built 12 Apr 2017 to 26 Sep 2017

On the affected vehicles the operation of the brake vacuum pump may be affected by material detaching from the timing belt caused by the ageing of the engine oil.

Fix: To rectify this issue a software update will be downloaded which will improve the vacuum diagnosis (in order to warn earlier about the risk of loss or reduction of braking assistance).

10,100 vehicles · built 17 Jan 2017 to 12 Jul 2017

Some vehicles may have been equipped with an incorrectly positioned fuel pipe.

Fix: Check fuel pipe positioning correct if necessary and fit protective sleeve.

4,861 vehicles · built 6 Oct 2020 to 21 Jan 2022

The rear toe link may have material loss over vehicle lifetime due to corrosion which weakens the part. This leads to a risk of breakage while driving. In case of breakage this leads to a reduced ability to control the vehicle.

Fix: Check and replace the rear toe link if necessary.

167,237 vehicles · built 8 Dec 2007 to 26 Jul 2013

The possibility that the lower metal engine protection guard could trap material between it and the underside of the engine exhaust system.

Fix: Replace the metal under engine protection guard with a different design to prevent the collection of material.

507 vehicles · built 12 Mar 2018 to 17 Sep 2021

Vauxhall Combo - Model Years 2021-23 may have been built with a Built-in Systems Interface Module (BSI) software not according to specification. In some cases there is a missing sound alert in case of hands off the steering wheel for more than 10 seconds during Lane Keeping Assist (LKA) Mode.

Fix: Program the BSI module with improved software.

1,761 vehicles · built 1 Apr 2021 to 20 Sep 2022

Under specific conditions (vacuum loss) the Hydraulic Brake Compensation (vacuum pump) may not get activated

Fix: Reprogram the Electronic Brake Control Module (EBCM) with improved software.

34,294 vehicles · built 13 Dec 2016 to 5 Oct 2020

Software does not allow the authorities to test according to regulation.

Fix: Re-flash the Body Control software.

6,361 vehicles · built 7 Nov 2019 to 16 May 2022

Insufficient tightening torque of the steering gear fastening bolts can lead to vibration or improper steering behaviour.

Fix: Check and replace the steering gear if necessary.

1 vehicles · built 2 Mar 2022 to 2 Mar 2022

On the affected vehicles equipped with a manual handbrake the efficiency of the handbrake and service brake may be compromised.

Fix: Check the rear brake caliper references and replace as necessary.

49 vehicles · built 22 Jan 2022 to 31 Jan 2022

A high voltage battery where there is a mismatch in the voltage of the individual cells.

Fix: Replace the HV traction battery.

3 vehicles · built 26 Nov 2019 to 30 Nov 2019

The High Voltage Harness might not be to the correct specification.

Fix: Check the harness conformity and replace it if necessary.

33 vehicles · built 15 Mar 2022 to 29 Apr 2022

The vehicles may have the wrong VIN printed on the �B pillar� VIN sticker.

Fix: Check and if necessary replace the �B pillar� VIN sticker.

15 vehicles · built 10 Mar 2022 to 10 Mar 2022

The passenger seatbelt warning chime might be inoperative.

Fix: Reprogram the Body Control Module software.

10,576 vehicles · built 17 Aug 2021 to 3 May 2022

Selective Catalytic Reduction (SCR) system does not heat up as required.

Fix: Replace the affected Urea Reservoir.

191 vehicles · built 20 Dec 2020 to 23 Apr 2021

Exterior door handles might stay open and the door will not be locked.

Fix: Check the four door handles and replace them if necessary.

36 vehicles · built 28 Oct 2021 to 27 Jan 2022

The front modular bench seat headrests may not be to specification and might not be locked correctly.

Fix: Check and if necessary replace the affected headrests and guides

638 vehicles · built 16 Nov 2021 to 17 Dec 2021

The customer might not be alerted to a malfunction of the turn indicator.

Fix: Update the Built-in System Interface (BSI) module with new software.

66,176 vehicles · built 28 Aug 2019 to 31 May 2021

The front suspension springs may not be correctly positioned in the strut assembly.

Fix: Check the front suspension springs and correct the position of the spring if necessary.

32 vehicles · built 17 Nov 2021 to 18 Nov 2021

A potential for an intermittent internal connection issue on the DC/DC chip of the on-board charger.

Fix: Check and if necessary replace the on-board charger and update with the latest software.

450 vehicles · built 8 Nov 2019 to 30 Sep 2020

The windscreen wipers might have a functionality issue at low ambient temperatures (below +3� degree Celsius)

Fix: Program the Built-in System Interface (BSI) module with the latest software.

2,153 vehicles · built 12 May 2021 to 8 Sep 2021

The rear spring centraliser might be welded incorrectly.

Fix: Add 3 weld spots to the rear spring centralisers.

53 vehicles · built 16 Apr 2021 to 20 Apr 2021

The bolts and nuts of both the control arms might be incorrectly tightened.

Fix: Replace the bolts and nuts of both the control arms and tighten to the correct specifications.

6 vehicles · built 12 Feb 2021 to 22 Feb 2021

The right rear brake calliper might not be built to specification.

Fix: Check the production date stamp of the right rear brake calliper and replace the brake calliper if necessary.

72 vehicles · built 11 Feb 2021 to 21 Mar 2021

The rear wheel hub the shock absorber and the brake calliper are possibly not tightened according to specification.

Fix: Check the affected bolted connections on the rear axle for correct tightening torque application and replace affected components if necessary.

17 vehicles · built 8 Jun 2020 to 8 Jun 2020

A fuel leak may occur due to a chafing condition between the fuel feed hose and the camshaft cover.

Fix: Check the fuel feed hose replace it if damaged and add a protection to the hose to prevent a future chafing condition.

5,163 vehicles · built 11 Jan 2018 to 5 Jun 2019

There is a risk that the Brake Pedal may fall down while driving resulting in the total loss of brake performance.

Fix: Check the assembly date range and replace the brake pedal box if affected.

173 vehicles · built 2 Feb 2021 to 29 Apr 2021

It may not be possible to engage the handbrake lever.

Fix: Check the handbrake lever locking mechanism and if necessary replace the handbrake lever.

305 vehicles · built 20 Feb 2021 to 5 Mar 2021

Noises may come from the rear wheel brake and wheel pinion socket due to incorrect tightening of the rear wheel hub bolts.

Fix: Replace the affected rear wheel hub bolts.

2 vehicles · built 10 Feb 2020 to 10 Feb 2020

Vehicles may have an engine cooling radiator air intake module sealing baffle missing.

Fix: Install the missing radiator air intake sealing baffle.

162 vehicles · built 9 Sep 2019 to 18 Sep 2019

Vehicles may be fitted with a non-conform accessory trailer hitch.

Fix: Check the batch number and if necessary replace the trailer hitch.

31 vehicles · built 17 Jan 2018 to 12 Nov 2020

The brake pedal may potentially stick as a result of high vehicle interior temperatures causing the brake lights to activate without brake pedal pressure.

Fix: To reprogram the electronic brake control module (EBCM) to enable a warning message to display.

62,957 vehicles · built 30 May 2012 to 26 Jun 2019

Possible damaged wheel bolt threads due to a production process deviation.

Fix: Check and if necessary replace the wheel bolts hub and wheel.

53 vehicles · built 26 Sep 2020 to 12 Nov 2020

Possible unexpected side airbag deployment due to insufficient electrical grounding.

Fix: Rework the affected ground studs to ensure sufficient electrical grounding.

21,068 vehicles · built 30 Jun 2020 to 4 Dec 2020

An incorrect calibration file for NOx calculation was used in production.

Fix: Reprogram the Reductant Control Module with the latest software.

974 vehicles · built 11 May 2016 to 20 Apr 2017

A possible short-circuit between the electrodes of the high voltage battery.

Fix: Replace the High Voltage Battery

1 vehicles · built 28 Nov 2019 to 28 Nov 2019

The Diesel Particle Filter (DPF) might be defective / develop cracks.

Fix: Replace the Diesel particular filters on all affected vehicles.

88 vehicles · built 11 Feb 2018 to 28 Jun 2018

Vehicle rear wheel hub bolts may not be tightened according to specification and/or the incorrect wheel hub may be installed

Fix: Check the bolt security and if necessary replace the rear wheel hubs

14 vehicles · built 25 Aug 2020 to 27 Aug 2020

Possible crack in the rear axle knuckle casting.

Fix: Check and if necessary replace the rear axle knuckle.

1 vehicles · built 25 Sep 2020 to 25 Sep 2020

The urea injector might block and lead to NOx emissions out of regulatory limits.

Fix: Updating the ECU software to avoid the future blockage of the urea injector

3,185 vehicles · built 1 Oct 2019 to 16 Mar 2020

Vehicles may have fuel tank strap bolts that are not tightened according to specification.

Fix: Check and re-tighten the bolts of all affected vehicles.

97 vehicles · built 28 Aug 2020 to 7 Sep 2020

Vehicles have been built with incorrect steering inner tie rods

Fix: Replacement of the steering inner tie rods.

299 vehicles · built 3 Dec 2019 to 28 Jan 2020

Possible leaky connection on the high pressure fuel pump.

Fix: Re-tighten the high pressure fuel pump and replace the fuel supply pipe.

2 vehicles · built 21 May 2019 to 14 Feb 2020

The optional Speed Limiter does not work.

Fix: Reprogramming of the Engine Control Module

68 vehicles · built 20 Sep 2019 to 4 Nov 2019

The ground terminal of the trailer hitch socket might be installed in an incorrect port.

Fix: Relocate the ground terminal in the trailer hitch socket from pin location 10 to location 3.

2 vehicles · built 9 Sep 2019 to 6 Nov 2019

On affected vehicles certain seat belts might stick when pulled out and retracted.

Fix: Replace the affected seat belts on the affected vehicles.

1,122 vehicles · built 21 May 2019 to 28 Jun 2019

The turbo charger oil return pipe may get damaged by cracks which may lead to oil leaks.

Fix: Replace the oil return pipes on affected vehicles

82 vehicles · built 22 Aug 2017 to 22 Jan 2019

Rear axle bolts may break or become loose

Fix: Check the fastening torque and replace affected bolts on all affected vehicles

39 vehicles · built 20 Aug 2019 to 25 Sep 2019

Water ingress into the passenger compartment due to poor wheel arch sealing may lead to airbag malfunction

Fix: Seal the wheel arch body seams. Replace wiring harness and airbag control unit if necessary

75 vehicles · built 16 Oct 2019 to 23 Oct 2019

Water ingress into the passenger compartment due to poor wheel arch sealing may lead to airbag malfunction

Fix: Seal the wheel arch body seams. Replace wiring harness and airbag control unit if necessary

945 vehicles · built 17 Jun 2019 to 20 Sep 2019

The clip of a fuel line bundle might chafe against the fuel pump hose.

Fix: Check the hose routing turn the clip by 180�. Replace the hose and add a grommet to the fuel hose if necessary.

8,489 vehicles · built 19 Jan 2017 to 28 Nov 2018

Affected vehicles may have a chafing condition on the fuel pipes.

Fix: Check and replace the fuel pipes as necessary add protectors to the pipes

2,015 vehicles · built 29 Mar 2019 to 23 Dec 2019

The front passenger seatbelt may not retain the passenger sufficiently in case of an accident with high impact.

Fix: Replacement of the front passenger seat belt with correct retention force specification.

7,178 vehicles · built 14 Sep 2018 to 25 Oct 2019

Steering columns were produced not according to specification

Fix: Replacement of the steering column

300 vehicles · built 22 Jun 2019 to 15 Jul 2019

Front seat frames may not be welded correctly

Fix: Check seat frame welds and replace front seats if necessary.

1,688 vehicles · built 3 Jul 2019 to 12 Aug 2019

Front seat frames may not be welded correctly

Fix: Check seat frame welds and replace front seats if necessary.

1,688 vehicles · built 3 Jul 2019 to 11 Jul 2019

The material thickness of the wheel rims might be out of specification

Fix: Check and replace the wheel rims if necessary.

55 vehicles · built 21 Aug 2019 to 29 Aug 2019

The rear seat centre belt might not be fixed correctly to the lower fastening point

Fix: Check and if necessary correct the fixation of the centre rear seat belt at the lower fastening point

10 vehicles · built 1 Jun 2019 to 1 Jun 2019

The lambda control may not work sufficiently which may result in a NOx limit exceedance

Fix: A software calibration for the lambda control

6,282 vehicles · built 28 Jun 2018 to 22 Mar 2019

The vehicle�s fixed roof luggage carrier rails may become loose.

Fix: Check and replace the fixed roof luggage carrier rails if necessary

20,447 vehicles · built 23 Nov 2011 to 29 May 2018

The rear end impact limiter might not have been installed in production.

Fix: Check if the rear end impact limiter is present and install one if required.

219 vehicles · built 10 Feb 2017 to 15 May 2017

The rear axle U-bolts may not be fastened according to specification.

Fix: Check the tightening torque of the rear axle U-bolts and replace where incorrect

20 vehicles · built 16 May 2018 to 9 Jul 2018

Potential for a reduction in braking power where the brake pedal is applied slowly and constantly.

Fix: Replacement of hydraulic brake and clutch system components.

1,100 vehicles · built 3 Jan 2017 to 29 Jun 2017

Incorrect crimping of the secondary parking brake cable ferrules.

Fix: Replacement of the secondary parking brake cables the adjuster and the adjustment nut.

6,270 vehicles · built 30 Jun 2018 to 13 Sep 2018

The parking brake lever might not lock in the engaged position or might disengage after application

Fix: Check the handbrake mechanism and replace if required

876 vehicles · built 25 Jun 2018 to 4 Feb 2019

The parking brake lever might not lock in the engaged position or might disengage after application

Fix: Check the handbrake mechanism and replace if required

740 vehicles · built 20 Mar 2018 to 13 Jan 2019

Movement of the wiring harness connector to the fan speed resistor can in rare circumstances lead to electrical stress.

Fix: Replacement the heating & ventilation system wiring harness with a redesigned connector plug and additional mounting points.

234,931 vehicles · built 2 Nov 2004 to 4 Nov 2014

Vehicles might deliver a higher diesel particulate rate than specified.

Fix: Check and if necessary replace the DPF. Some models will also need a software change.

500 vehicles · built 20 Feb 2018 to 27 Jun 2018

Vehicles might deliver a higher diesel particulate rate than specified.

Fix: Check and if necessary replace the DPF. Some models will also need a software change.

500 vehicles · built 20 Feb 2018 to 27 Jun 2018

The bolts securing the rear axle beam to the vehicle underbody could break.

Fix: Replace the rear axle affected bolts.

539 vehicles · built 15 Mar 2010 to 26 Mar 2018

lambda control may result in NOx limit being exceeded during the vehicle lifetime.

Fix: An engine management system software upgrade will be installed.

53,981 vehicles · built 5 Jan 2018 to 9 Apr 2019

lambda control may result in NOx limit being exceeded during the vehicle lifetime.

Fix: An engine management system software upgrade will be installed.

53,981 vehicles · built 5 Jan 2018 to 9 Apr 2019

The hill start hold feature exceeds the correct time specification.

Fix: A Software Update to the Electronic Brake Control Module.

42,603 vehicles · built 19 May 2009 to 31 Jan 2014

The hill start hold feature exceeds the correct time specification.

Fix: A Software Update to the Electronic Brake Control Module.

42,603 vehicles · built 19 May 2009 to 31 Jan 2014

The hill start hold feature exceeds the correct time specification.

Fix: A Software Update to the Electronic Brake Control Module.

42,603 vehicles · built 19 May 2009 to 31 Jan 2014

The Central Door Locking (CDL) might unlock the doors while the vehicle is parked or the doors can only be unlocked with the mechanical key. This is caused by inadequate sealing allowing water ingress into the door connector

Fix: Seal both A-pillar areas above the door connectors with sealer to avoid water ingress to the door connector.

335 vehicles · built 6 Mar 2017 to 11 Apr 2018

Extended brake pedal travel and a reduction in braking power where the brake pedal is applied slowly and constantly.

Fix: Replace numerous brake and clutch hydraulic components.

37,167 vehicles · built 23 Mar 2015 to 14 Aug 2018

Zafira B Right Hand Drive (RHD) - Electronic Climate Control (ECC) a small number of incidents of potential melting and fires within the blower motor regulator of the Heating Ventilation and Air Conditioning (HVAC) unit of Zafira B RHD vehicles with Electronic Climate Control (ECC). There is a small risk that in rare circumstances melting and fire incidents may occur in the HVAC system

Fix: Vauxhall Authorised Repairers are instructed to Carry out the following rework steps according to the instructions: A Install the water deflector B Replace the blower motor C Replace the heater fan motor regulator D Replace the wiring harness of the HVAC housing.

47,280 vehicles · built 7 Mar 2005 to 6 Jan 2014

Unexpected opening of the hood while driving.

Fix: Check operation and repair if required.

6,167 vehicles · built 2 Feb 2018 to 29 May 2018

On a certain number of Insignia B - Model Year 18 the clip of a fuel line bundle might chafe against the fuel pump hose resulting in fuel leaks and in the worst case in a risk of fire.

Fix: Vauxhall Authorised Repairers will check the hose routing to turn the clip by 180� and to replace the hose and add a grommet to the fuel hose if necessary on all affected vehicles where the hose has signs of damage or leakage

2,833 vehicles · built 19 Jan 2017 to 4 Sep 2017

A certain number of Grandland X - Model Year 18 the piping seam of the front leather seat cover does not open as required in case of a seat airbag deployment.

Fix: Replace all affected leather front seat leather covers.

122 vehicles · built 19 Sep 2017 to 4 Dec 2017

On a certain number of Grandland X - Model Year 18 with LCI engine (D20DTH) Engine oil might leak from an oil plug in the cylinder block. This could lead to oil stains on the floor low engine oil volume (warning on dashboard if volume is low) or MIL on if the oil pressure is low.

Fix: Vauxhall Authorised Repairers are instructed to tighten the oil plug in the cylinder block on the timing case side to 42 Nm

1 vehicles · built 5 May 2018 to 5 May 2018

A certain number of Insignia A - Model Year 17 the front seat belt buckles may not be produced according specification. In a worst case the seat belt buckles may separate from the seat frame in the event of an accident.

Fix: Vauxhall Authorised Repairers are instructed to check and if necessary replace the seat belt buckles on all affected vehicles.

225 vehicles · built 3 Mar 2017 to 21 Mar 2017

On a certain number of Astra K - Model Year 2016-2017 (Only converted UK Police vehicles are affected) the front brake hoses might be incorrectly installed. This can lead to contact with the drive shaft boots finally resulting in failure/leakage.

Fix: Vauxhall authorised repairers or Police Workshops are asked to reroute the brake hoses and to inspect the brake hose installation if necessary replace any damaged parts to guarantee accurate functionality of the brakes.

713 vehicles · built 18 Aug 2015 to 5 Oct 2017

We would like to make you aware that on a certain number of Astra J GTC Insignia B - Model Year 18 there is the possibility of oil leakage from the turbo charger oil feed pipe. In worst case the spilled oil may inflame on hot engine parts. Possible oil leakage from turbo charger oil feed pipe. In worst case the spilled oil may inflame on hot engine parts.

Fix: check/adjust turbo oil feed pipe connector on all affected vehicles

3 vehicles · built 29 Jan 2018 to 29 Jan 2018

We would like to make you aware that on a certain number of Astra J GTC Insignia B - Model Year 18 there is the possibility of oil leakage from the turbo charger oil feed pipe. In worst case the spilled oil may inflame on hot engine parts. Possible oil leakage from turbo charger oil feed pipe. In worst case the spilled oil may inflame on hot engine parts.

Fix: check/adjust turbo oil feed pipe connector on all affected vehicles

3 vehicles · built 26 Jan 2018 to 26 Jan 2018

We would like to make you aware that on a certain number of Astra J GTC Insignia B - Model Year 18 there is the possibility of oil leakage from the turbo charger oil feed pipe. In worst case the spilled oil may inflame on hot engine parts. Possible oil leakage from turbo charger oil feed pipe. In worst case the spilled oil may inflame on hot engine parts.

Fix: check/adjust turbo oil feed pipe connector on all affected vehicles

3 vehicles · built 24 Jan 2018 to 24 Jan 2018

on a certain number of Movano B - Model Year 17 and 18 the alerts on failures from power steering assist pump might not be indicated in the instrument cluster due to incorrect calibration file in Instrument Cluster. OBD System does not work to specification because a potential failure on the power steering assist pump might not be indicated in the instrument cluster

Fix: Apply the new calibration file for Instrument Cluster

540 vehicles

on a certain number of Movano B - Model Year 16 and 17 with LWK or L0D engine there are some problems of the OBD (on Board Diagnostic) which should be indicated but do not trigger the MIL (Malfunction Indication Lamp). occurs Possible faults which should be indicated but do not trigger the MIL (Malfunction Indication Lamp). Under worst-case conditions the OBD would recognize a failure on Exhaust System components (e.g. components of the Exhaust Gas Recirculation EGR) but would not display the failure with a malfunction indicator lamp.

Fix: Reprogram the K20 Engine Control Module via SPS with the latest software available on TIS2WEB:

76 vehicles

on a certain number of Antara (RHD) with 2.0L Diesel Engine Model Year 2007 - 2010 there is a potential for a fuel leak caused by a partial or complete disconnection of a fuel feed hose connector. This fuel leak leads to engine stalling and in a worst case it might potentially result in an engine bay fire. This fuel leak leads to engine stalling and in a worst case it might potentially result in an engine bay fire. No reported cases of fires.

Fix: to Check and correct the fuel feed hose routing replace the fuel feed hose quick connector retainer and apply a warning sticker to advice that the retainer is a single-use part

4,697 vehicles

In a certain number of Insignia B - Model Year 18 the outer rear seatbelts might be incorrectly routed at anchor point. In the event of a frontal crash this may lead to a higher load than the belt system is designed for or it may allow the passenger to slip through under the seatbelt.

Fix: Vauxhall Authorised Repairers are instructed to check the seatbelt and change the routing if necessary on all affected vehicles.

15,637 vehicles

on a certain number of Insignia B - Model Year 18 with special color option (RPO code: GAF) the windscreen might not be installed correctly and can potentially detach from body. The one affected vehicle was repaired in the Luton Technical Centre

Fix: Check the bonding of the windscreen and rework if required.

1 vehicles

The Steering column may become detached from the rack due to incorrectly tightened bolt.

Fix: On affected vehicles check for presence of retaining nut. If present tighten nut to specified torque. If nut is absent replace bolt and screw and tighten to specified torque. THE MANUFACTURER HAS ADVISED NOT TO DRIVE THE VEHICLE.

160 vehicles · built 1 Sep 2015 to 9 Aug 2017

on a certain number of Crossland X - Model Year 18 the Fastening Nut of the Rear Axle Hub might potentially become loose. This can lead to a separation of the rear wheel resulting in a loss of steering control.

Fix: Vauxhall Authorised Repairers are instructed to check both Rear Axle Hub Nuts for correct application of the securing punch if correct no further action. if incorrect replace hubstud and nut assembly

3 vehicles

The engine pistons may not be according to specification leading to oil entry in the inlet circuit. In a worst case this may cause an increased engine rpm for a few seconds possibly resulting in a total engine failure.

Fix: Perform a test of the engine to establish if the pistons are to specification. Where necessary the engine will be replaced.

52 vehicles · built 9 Oct 2017 to 1 Dec 2017

The engine pistons may not be according to specification leading to oil entry in the inlet circuit. In a worst case this may cause an increased engine rpm for a few seconds possibly resulting in a total engine failure.

Fix: Perform a test of the engine to establish if the pistons are to specification. Where necessary the engine will be replaced.

52 vehicles · built 9 Oct 2017 to 1 Dec 2017

An incorrect surface treatment on the fuel filter collar may lead to breakage of the diesel filter strap resulting in vibration and noise from the engine compartment. In the case of any mechanical pulses when driving with a broken strap or as a consequence of an accident this could result in breakage of the fuel pipes with subsequent leakage.

Fix: Recall the vehicles that are likely to be affected and replace the diesel filter strap.

402 vehicles · built 1 Dec 2016 to 9 Feb 2017

3rd row seat retaining bolts and 2nd row seat belt shoulder anchor retaining bolts may not be tightened to the correct specification

Fix: Re-tighten the 2nd rear seat shoulder belt bolts the 3rd row seat bolts and the 3rd row seat shoulder belt buckle bolts to the correct specification .

131 vehicles · built 20 Jul 2016 to 2 Feb 2017

A deviation in the supplier manufacturing printing process caused a high viscosity in the black print which might lead to a loss of adhesion over vehicle lifetime.

Fix: Until such time a final remedy is determined affected vehicles will have additional fixation added to secure the glass roof to the vehicle.as an interim measure

10,168 vehicles · built 4 Jun 2012 to 28 Oct 2016

A deviation in the supplier manufacturing printing process on the glass panel caused may cause a loss of adhesion over vehicle lifetime. This may cause the sunroof panel to detach.

Fix: On affected vehicles rework the adhesive connection between the sunroof panel and the vehicle body.

10,168 vehicles · built 4 Jun 2012 to 28 Oct 2016

Due to a possible contamination of the tooth segment the handbrake pawl may not latch correctly. This may cause the handbrake to disengage.

Fix: On affected vehicles Replace the parking brake lever assembly.

1,530 vehicles · built 26 Aug 2016 to 30 Jan 2017

Due to a possible contamination of the tooth segment the handbrake pawl may not latch correctly. This may cause the handbrake to disengage.

Fix: On affected vehicles Replace the parking brake lever assembly.

1,530 vehicles · built 26 Aug 2016 to 23 Jan 2017

A front seat side air bag may not deploy as intended

Fix: On affected vehicles replace the airbag module assembly

289 vehicles · built 25 Aug 2016 to 1 Dec 2016

A front seat side air bag may not deploy as intended

Fix: On affected vehicles replace the airbag module assembly

289 vehicles · built 25 Aug 2016 to 1 Dec 2016

A front seat side air bag may not deploy as intended

Fix: On affected vehicles replace the airbag module assembly

289 vehicles · built 25 Aug 2016 to 1 Dec 2016

The longitudinal control arm of the rear axle may not be correctly fastened. This may cause the arm to break and/or detach.

Fix: On affected vehicles check the torque of the screw connection on the longitudinal rod and replace nuts bolts or rear axle where necessary.

2,601 vehicles · built 18 Jul 2013 to 21 Jan 2016

The driver's air bag may not deploy as intended

Fix: On affected vehicles replace the airbag module assembly

2 vehicles · built 25 Aug 2016 to 1 Dec 2016

It has been identified that the side board/tail board hinges may fail. This could result in the detachment of the side board whilst the vehicle is in motion.

Fix: Recall all affected vehicles to install additional safety reinforcement brackets to the side boards/tail board of the body and check the existng hinges and repair if necessary.

825 vehicles · built 21 Jul 2010 to 7 May 2015

A front seat side air bag may not deploy as intended

Fix: On affected vehicles replace the airbag module assembly

289 vehicles · built 25 Aug 2016 to 1 Dec 2016

A roof side rail air bag may not deploy as intended

Fix: On affected vehicles replace the airbag module assembly

102 vehicles · built 25 Aug 2016 to 1 Dec 2016

The passenger air bag may not deploy as intended

Fix: On affected vehicles replace the airbag module assembly

102 vehicles · built 25 Aug 2016 to 1 Dec 2016

An incorrect front brake hose may have been fitted which may allow brake fluid to leak

Fix: On affected vehicles check and where necessary replace front brake hoses

9 vehicles · built 18 Aug 2016 to 30 Aug 2016

Due to a manufacturing process deviation the toothed rack of the steering gear might break under extensive force application i.e. when manoeuvring at slow speed.

Fix: Recall the vehicles that are likely to be affected and check the build date of the steering rack. Where the steering rack is proved to be from the affected batch the steering rack will be replaced.

3,333 vehicles · built 18 Oct 2014 to 28 Jan 2015

Due to a manufacturing process deviation the toothed rack of the steering gear might break under extensive force application i.e. when manoeuvring at slow speed.

Fix: Recall the vehicles that are likely to be affected and check the build date of the steering rack. Where the steering rack is proved to be from the affected batch the steering rack will be replaced.

3,333 vehicles · built 27 Oct 2014 to 5 Jan 2015

Due to a manufacturing process deviation the toothed rack of the steering gear might break under extensive force application i.e. when manoeuvring at slow speed.

Fix: Recall the vehicles that are likely to be affected and check the build date of the steering rack. Where the steering rack is proved to be from the affected batch the steering rack will be replaced.

3,333 vehicles · built 18 Oct 2014 to 28 Jan 2015

There is the possibility of water penetration into the vent hose resulting in water ingress into the vacuum pump over the wire harness and into the relay box. In the worst case a short circuit may lead to a risk of fire.

Fix: On affected vehicles add a spray deflector to avoid water ingress into the vent hose replace the electronic vacuum pump/relay box assembly and apply special grease to the electrical terminals.

4,046 vehicles · built 3 Jul 2012 to 3 Sep 2014

Repeated occupant movement into the seat over the fastener leading to bending of the steel cable. Possible damage of safety belt anchor cable - worst case: Loss of seat belt function

Fix: This recall is additional to Recall R/2015/201.Improved parts are now available and the manufacturer will now replace the outer pre tensioners.

67,142 vehicles · built 12 Feb 2010 to 11 Feb 2016

Vehicles equipped with stop/start system might have a starter motor failure while driving due to thermal damage of the starter cable.

Fix: Authorised Repairers will Rework the starter motor cable. If necessary replace the starter the starter cable and the starter cable nut.

5,003 vehicles · built 1 Nov 2013 to 9 Jun 2015

The passenger air bag may not meet the correct specification. In the possible event of a frontal collision front passenger airbag might not deploy as intended.

Fix: On affected vehicles replace passenger air bag module.

1,745 vehicles · built 26 Jul 2016 to 31 Aug 2016

The passenger air bag may not meet the correct specification. In the possible event of a frontal collision front passenger airbag might not deploy as intended.

Fix: On affected vehicles replace passenger air bag module.

1,745 vehicles · built 19 Jul 2016 to 9 Nov 2016

It has been identified that the Exhaust Gas Recirculation (EGR) valve pipe may fail/break. This will allow hot exhaust gases to escape and potentially damage component in the surrounding area.

Fix: Recall all affected vehicles and replace the EGR valve pipe.

8,391 vehicles · built 18 Jul 2013 to 15 Jan 2016

It has been identified on certain Mokka models produced between 2013 & 2017 equipped with a rear bicycle carrier that if the rear bicycle carrier is not folded back into its correct stowed position after use then the body control module will not recognise this and will not illuminate the vehicles rear/tail lights when required.

Fix: Recall all affected vehicles to attach a sticker on the rear bicycle carrier instructing driver how to stow the rear bicycle carrier correctly.

857 vehicles

Due to an incorrect tightening operation in the production plant the locking function of the hood might not work correctly. This may allow the bonnet to open whilst the vehicle is in motion

Fix: On affected vehicles check tightness of securing bolts and replace where necessary

7,866 vehicles · built 6 Jun 2014 to 26 Apr 2016

Affected vehicles may have been built with an incorrect crimping of the turbocharger oil feed pipe connector. This may cause oil leakage which may lead to odours smoke oil specks on the floor or engine failure. In the worst case a fire in the engine compartment could occur.

Fix: On affected vehicles replace the turbo charger oil feed pipe.

76 vehicles · built 22 Sep 2015 to 27 Oct 2015

The thread on the swivel pin of the track rod end might not be to specification. Therefore when the nut was tightened onto the thread the correct clamping force may not have been attained. After high mileage damage might occur and develop. If not attended to there is a possiblility that the component might fail and steering control would be lost.

Fix: Recall the vehicles that are likely to be affected and check the thread on the swivel joint of the track rod end. Where it does not conform to specification replace the track rod end.

537 vehicles · built 7 Apr 2016 to 20 Apr 2016

The thread on the swivel pin of the track rod end might not be to specification. Therefore when the nut was tightened onto the thread the correct clamping force may not have been attained. After high mileage damage might occur and develop. If not attended to there is a possiblility that the component might fail and steering control would be lost.

Fix: Recall the vehicles that are likely to be affected and check the thread on the swivel joint of the track rod end. Where it does not conform to specification replace the track rod end.

537 vehicles · built 13 Apr 2016 to 19 Apr 2016

Water may penetrate into the Electronic Brake Control Module (EBCM) connector. In the worst case water can enter the EBCM where a short circuit may lead to a risk of fire. Warning before the fire element could occur is: flashing warning lamp which will give sufficient warning for the vehicle to be parked safely or if nearby taken to the dealership for repair.

Fix: Recall the vehicles that are likely to be affected and check if the water cowl fastening clip correctly seals the water channel and that proper sealing of the EBCM connector is ensured. If necessary the EBCM and/or the hydraulic modulator will be replaced.

2,143 vehicles · built 29 Apr 2015 to 27 Nov 2015

In the event the heater fan resistor thermal fuse is affected by a combination of several factors there is a possible risk of fire.

Fix: Replace the resistor fuse with modified type. Fit new moulding to base of windscreen and where not already done so replace heater motor assembly.

231,572 vehicles · built 10 Feb 2005 to 24 Oct 2014

One or both bolts retaining the passenger air bag may have been omitted during production. As a result the airbag may not deploy as intended during a frontal collision.

Fix: On affected vehicles check bolts are present for tightness and fit new bolts where required.

22 vehicles · built 18 Sep 2013 to 1 Dec 2014

Water ingress to the relay on the electrical vacuum pump may cause a short. In extreme instances this may lead to fire.

Fix: On affected vehicles replace Vacuum Pump/Relay Assembly and apply special grease to electrical connectors

4,046 vehicles · built 3 Jul 2012 to 3 Sep 2014

Due to insufficient coating during manufacture the drive-shafts) may corrode and fracture. In the event that the drive-shaft is fractured the vehicle loses drive but steering and braking will be still be available.

Fix: On affected vehicles replace both drive shafts.

63 vehicles · built 14 Dec 2014 to 10 Mar 2015

Due to insufficient coating during manufacture the drive-shafts) may corrode and fracture. In the event that the drive-shaft is fractured the vehicle loses drive but steering and braking will be still be available.

Fix: On affected vehicles replace both drive shafts.

63 vehicles · built 14 Dec 2014 to 10 Mar 2015

The tightening torque of both hood primary latch bolts may not be to specification and cause the locking function of the hood to not work correctly. The loosening of the hood latch screws under the influence of vibrations together with the aerodynamic pressure under the hood can lead to the bonnet not staying in the closed position.

Fix: Recall the vehicles that are likely to be affected and check the tightening torque of both hood primary latch bolts. Where necessary the bolts will be replaced.

2,364 vehicles · built 26 Jun 2013 to 3 Sep 2015

In the event the radiator cooling fan is blocked there is a risk that an electrical short circuit can occur. This in turn causes damage to the cooling fan module and in the worst case could potentially result in a vehicle fire.

Fix: On affected vehicles check for presence of and if necessary remove battery cover. Ensure that the radiator cooling fan is not obstructed or blocked in anyway. Fit new additional wiring harness which will prevent damage to the radiator wiring harness.

48,157 vehicles · built 19 May 2009 to 15 Apr 2011

The servo vacuum pump may fail causing a hard bake pedal loss of engine power and the vehicle may adopt limp home mode. A warning lamp may also illuminate.

Fix: On affected vehicles replace vacuum pump.

598 vehicles · built 2 Oct 2015 to 15 Oct 2015

The servo vacuum pump may fail causing a hard bake pedal loss of engine power and the vehicle may adopt limp home mode. A warning lamp may also illuminate.

Fix: On affected vehicles replace vacuum pump.

598 vehicles · built 2 Oct 2015 to 15 Oct 2015

Vauxhall has conducted an in depth investigation of fires in Zafira B models. Vauxhall has presented the evidence to DVSA and analysis has determined the root cause is improper repair to heater blower motor resistors. These actions are outside of Vauxhall�s design specifications and authorised maintenance processes.

Fix: At the request of DVSA Vauxhall is now reclassifying its ongoing rework activity to a safety recall. The recall entails replacing the resistor pack and any other faulty components to return the heating and ventilation system to its original design condition.

234,921 vehicles · built 10 Feb 2005 to 24 Oct 2014

The connection between the steering knuckle and the lower control arm may not be assembled correctly. If this condition is evident the connection could become insecure. The event can happen suddenly and unexpectedly in which case the vehicle is no longer controllable.

Fix: Recall the vehicles that are likely to be affected and inspect the connection between the steering knuckle and the lower control arm on both sides of the vehicle. Where necessary the connection will be reassembled correctly.

421 vehicles · built 30 Jun 2014 to 28 Sep 2015

The connection between the steering knuckle and the lower control arm may not be assembled correctly. If this condition is evident the connection could become insecure. The event can happen suddenly and unexpectedly in which case the vehicle is no longer controllable.

Fix: Recall the vehicles that are likely to be affected and inspect the connection between the steering knuckle and the lower control arm on both sides of the vehicle. Where necessary the connection will be reassembled correctly.

421 vehicles · built 30 Jun 2014 to 28 Sep 2015

The front seat belts on vehicles with height adjustable seats may not react as designed during a collision.

Fix: On affected vehicles; Initially check and if necessary replace the steel cable linking the pretensioner to the seat. At a later date the outer pretensioner will be replaced with an improved version.

63,462 vehicles · built 5 Feb 2009 to 31 Aug 2015

The gears within the steering rack may not have been manufactured to the correct specification which may allow them to crack over a period of time. Prolonged use could cause loss of steering control.

Fix: On affected vehicles replace steering gear assembly

8,883 vehicles · built 30 Jun 2015 to 30 Jul 2015

The gears within the steering rack may not have been manufactured to the correct specification which may allow them to crack over a period of time. Prolonged use could cause loss of steering control.

Fix: On affected vehicles replace steering gear assembly

8,883 vehicles · built 23 Jun 2015 to 29 Jul 2015

The gears within the steering rack may not have been manufactured to the correct specification which may allow them to crack over a period of time. Prolonged use could cause loss of steering control.

Fix: On affected vehicles replace steering gear assembly

8,883 vehicles · built 23 Jun 2015 to 29 Jul 2015

The front seats are equipped with lap and shoulder belt pretentioners. In certain head on or rear end collisions the lap belt pretentioner will deploy but not lock in the loaded position. This can increase the risk of injury when the conditions are met. Parts for the recall will not be available until October 2015.

Fix: Recall the vehicles that are likely to be affected and replace both front pretentioners with lap belt.

7,476 vehicles · built 16 Dec 2011 to 2 Mar 2013

In order for proper regeneration of the Diesel Particle Filter (DPF) system the vehicle in the active regeneration mode directs the driver by illuminating the DPF warning light to drive the vehicle at constant speed without interruption until the DPF warning light turns off. In the event that the driver ignores the DPF warning light and the corresponding direction the DPF system as well as exhaust pipe will be abnormally overheated. This may cause a fire at the Lower Engine Compartment Cover located near the DPF system and exhaust pipe.

Fix: Recall the vehicles that are likely to be affected and initially remove and discard the Lower Engine Compartment Cover. When parts are available the vehicles will be recalled to have the new Lower Engine Compartment Cover fitted.

22,373 vehicles · built 3 Nov 2010 to 26 May 2015

Repeated key insertion could create intense wear condition on the trigger of the ignition cylinder internal component. As consequence Engine starter motor might self-crank and the vehicle moves involuntarily if the ignition key has been left in the ignition lock cylinder in the LOCK (OFF) position and a gear engaged. The concern only affects vehicles with manual transmission.

Fix: Recall the vehicles that are likely to be affected and fit a modified ignition Key cylinder.

2,803 vehicles · built 3 Mar 2006 to 18 Jul 2011

On affected vehicles there is a potential chafing condition between an engine wiring harness and the transmission housing which might cause miscellaneous engines failures e.g. engine telltale on illuminates vehicle may not start or the engine stalls during driving.

Fix: Reroute loom on affected vehicles. If necessary repair or replace loom.

1,004 vehicles · built 2 Oct 2013 to 8 Jan 2015

Moisture can ingress and accumulate inside the ABS control unit. Excessive accumulation of moisture may cause a fire.

Fix: On affected vehicles install an additional ABS module protection cover.

15,271 vehicles · built 20 Oct 2003 to 25 Jul 2008

Moisture can ingress and accumulate inside the ABS control unit. Excessive accumulation of moisture may cause a fire.

Fix: On affected vehicles install an additional ABS module protection cover.

15,271 vehicles · built 20 Oct 2003 to 25 Jul 2008

Moisture can ingress and accumulate inside the ABS control unit. Excessive accumulation of moisture may cause a fire.

Fix: On affected vehicles install an additional ABS module protection cover.

15,271 vehicles · built 20 Oct 2003 to 25 Jul 2008

Due to a gradual gas leak inside the left-hand tailgate strut the strut may become unable to support the opened tailgate. The tailgate may drop abruptly after first opening normally potentially causing serious injuries to persons present in the opening range of the tailgate.

Fix: Recall the machines that are likely to be affected and replaced the left hand gas strut.

10,130 vehicles · built 4 Jul 2008 to 19 Mar 2015

It is possible for the servo mounting bolts to loosen. If the noises are ignored over time it is possible for the brakes to be compromised.

Fix: Recall the vehicles that are likely to be affected and replace the brake pedal/servo mounting nuts.

780 vehicles · built 12 Jun 2014 to 6 Oct 2014

18 inch alloy wheels may develop cracking at high mileages in excess of 62000 miles. This may lead to a loss of clamping force at the wheel bolts and in a worse case scenario wheel detachment.

Fix: On affected vehicles replace all four wheels.

37 vehicles · built 21 Jun 2012 to 27 Feb 2015

The integrity of the front seat bench frame for the passengers may be compromised because of non-compliance during the manufacturing processes. Customer may hear noises coming from underneath the bench. They may also notice some cracking on the seat frame angles. If the seat fails during a collision the passengers have an elevated risk of injury.

Fix: Recall the vehicles that are likely to be affected and inspect the seat frame. Replace the seat where necessary.

1,650 vehicles · built 21 May 2014 to 14 Oct 2014

The front dual passenger seat may fail as the welded seams may not be to specification.

Fix: Recall the vehicles that are likely to be affect and inspect the seat frame and where necessary replace the frame.

395 vehicles · built 1 Aug 2014 to 11 Mar 2015

The lower wishbone fixing bolts might not have been tightened to the correct specification. This could lead to steering wheel noise and vibration possibly affecting steering direction while driving or accelerating (e.g. pulling to one side).

Fix: On affected vehicles check tightness of bolts. If necessary replace bolts and tighten to correct specification.

687 vehicles · built 21 May 2014 to 14 Oct 2014

The parking brake cable may not have been assembled correctly which can result in either the inability to apply the parking brake or the inability to release the parking brake.

Fix: Recall the vehicles that are likely to be affected and replace the parking brake cable.

780 vehicles · built 12 Jun 2014 to 6 Oct 2014

A small number of steering knuckles on hub swivels have been manufactured incorrectly. In time these knuckles might fail with the attendant loss of directional control of the vehicle.

Fix: Recall the vehicles that are likely to be affected and check the production date code on steering knuckles fitted to both sides. Replace the steering knuckles where required.

6,319 vehicles · built 28 Apr 2014 to 10 Jun 2014

If the radiator-cooling fan becomes blocked there is a risk that an electrical short circuit can occur. This in turn could cause damage to the cooling fan module and in the worst case potentially resulting in a vehicle fire.

Fix: Recall the vehicles that are likely to be affected to programme the Engine Control Module with the latest software.

681 vehicles · built 27 Feb 2009 to 1 Dec 2010

In the event the radiator cooling fan is blocked there is a risk that an electrical short circuit can occur. This in turn causes damage to the cooling fan module and in the worst case could potentially result in a vehicle fire.

Fix: In the first instance the battery cover must be removed to prevent overheating of the wiring/module. The cover should be disposed of and must not be refitted at any time. Check the cooling fan is not obstructed or blocked in anyway In approximately in 4 to 6 months-time an adapter wiring harness will become available and Authorised Repairers will be instructed to install this harness to the cooling fan module. This is now closed and superceeded by 16-C-004

48,155 vehicles · built 19 May 2009 to 15 Apr 2011

The buckles on seat belts fitted to the 2nd row of seats may have a weakness created during the manufacturing process. This weakness may allow the buckle to inadvertently open during a collision.

Fix: On affected vehicles check the traceability codes of the 2nd row seat belts. Replace those belts which have an affected code.

752 vehicles · built 9 Oct 2014 to 11 Nov 2014

Affected vehicles may have had a damaged passenger airbag module installed during production. In the event of a frontal collision gas escaping during deployment of the airbag may cause injuries to vehicle passenger(s).

Fix: Replace passenger airbag.

451 vehicles · built 19 Jun 2014 to 21 Jul 2014

THE MANUFACTURER HAS RECOMMENDED THAT AFFECTED VEHICLES ARE NOT DRIVEN UNTIL CHECKED BY THEIR OFFICIAL AGENTS. The steering system may not have been produced according to specification. There is a risk that the steering intermediate shaft may break while driving resulting in the loss of steering control.

Fix: The affected vehicles must not be driven until a new intermediate shaft that does meet the manufacturer's specification has been fitted.

69,218 vehicles · built 6 Feb 2014 to 28 Sep 2014

THE MANUFACTURER HAS RECOMMENDED THAT AFFECTED VEHICLES ARE NOT DRIVEN UNTIL CHECKED BY THEIR OFFICIAL AGENTS. The steering system may not have been produced according to specification. There is a risk that the steering intermediate shaft may break while driving resulting in the loss of steering control.

Fix: The affected vehicles must not be driven until a new intermediate shaft that does meet the manufacturer's specification has been fitted.

69,218 vehicles

THE MANUFACTURER HAS RECOMMENDED THAT AFFECTED VEHICLES ARE NOT DRIVEN UNTIL CHECKED BY THEIR OFFICIAL AGENTS. The steering system may not have been produced according to specification. There is a risk that the steering intermediate shaft may break while driving resulting in the loss of steering control.

Fix: The affected vehicles must not be driven until a new intermediate shaft that does meet the manufacturer's specification has been fitted.

69,218 vehicles · built 6 Feb 2014 to 28 Sep 2014

The drivers airbag may not deploy in the case of a frontal collision. This because the passenger airbag pigtail is not to specification.

Fix: Recall the vehicles that are likely to be affected to replace the passenger airbag pigtail.

7,190 vehicles · built 8 Mar 2002 to 3 Sep 2003

It is possible that the steering wheel securing bolt may not have been tightened to the correct specification. This should be identified to the driver by a loose steering wheel. However in extreme cases if the driver does not take notice of the looseness then the wheel could detach causing loss of control of the vehicle.

Fix: Recall all the affected vehicle and re-secure the steering wheel securing bolt.

102 vehicles · built 11 Dec 2012 to 31 Dec 2012

A small number of Vauxhall Combo D models may have a brake servo vacuum pipe connector that could break resulting in an unexpected hard brake pedal and reduced braking performance.

Fix: Check and if necessary to replace the brake servo vacuum pipe with connector.

498 vehicles · built 4 Jul 2012 to 4 Aug 2012

It is possible that a number of vehicles may have had the brake system filled with the incorrect brake fluid which can cause corrosion in the hydraulic ABS modulator. This can cause internal valves to stick which can result in possible longer brake pedal travel. In extreme cases this could result in increased brake pedal travel and stopping distances.

Fix: Recall all affected vehicles to check the ABS modulator and to replace the brake fluid. If found defective replace the hydraulic ABS modulator.

4,403 vehicles

Seat-belt buckle for the double cab second seat row may separate from seat connector under load.

Fix: Check all seat-belt buckles of the second seat row according to the following rework instruction and install a new seat-belt buckle if necessary

63 vehicles · built 24 Apr 2012 to 6 Jul 2012

Seat-belt buckle for the double cab second seat row may separate from seat connector under load.

Fix: Check all seat-belt buckles of the second seat row according to the following rework instruction and install a new seat-belt buckle if necessary

63 vehicles · built 24 Apr 2012 to 6 Jul 2012

It is possible that the internal contact resistance of the crimped joints for the grounding between the throttle position sensor (TPS) and engine control module may increase due to engine vibration. This can lead to an increased TPS voltage output which could lead to an increase in engine revolutions whilst at idle without any throttle input.

Fix: Recall all affected vehicles for the installation of a new wiring harness.

4 vehicles · built 1 Sep 1998 to 15 Mar 1999

The parking brake may not hold in the applied position as a result of a nonconformity in the manufacturing process which affects the hardness of the ratchet and pawl material.

Fix: Recall the vehicles that are likely to be affected to check the production date of the handbrake lever assembly and replace if necessary.

12,267 vehicles · built 1 Aug 2009 to 23 Aug 2010

Due to the insufficient strength of the material used in the brake pedal bearing it is possible that the bearing could fail when extreme force is applied to it during heavy or extreme braking.

Fix: Recall all affected vehicles and replace the brake pedal bearing.

405,690 vehicles · built 1 Sep 2006 to 15 Mar 2011

It is possible that the rear wheel bearing has been damaged whilst it was assembled onto the stub axle. This should be identified by excessive noise however in the worst case if not detected it could result in bearing failure and the detachment of the wheel and hub.

Fix: Recall all the affected vehicles and replace the wheel bearings with new items which will have protective sleeves to aid correct installation.

190 vehicles · built 15 Dec 2009 to 22 Apr 2010

An insufficient paint adhesion to the fuel tank sheet metal surface could lead to corrosion resulting in a fuel odour/leak.

Fix: The fuel tank will be checked for delamination of the paint surface and wax applied as a preventative measure. If necessary the fuel tank will be replaced.

16,332 vehicles · built 21 Jun 2003 to 30 Apr 2007

The spare wheel carrier winch system may allow the spare wheel to be loosely installed after the customer has used the winch. In this condition the spare wheel might move during driving which may damage and eventually break the cable and guiding pin of the winch system. In this worst case the spare wheel would become detached from the vehicle.

Fix: Recall the vehicles that are likely to be affected to replace the complete spare wheel winch system.

480 vehicles · built 10 Mar 2009 to 27 Aug 2010

Risk that the primary handbrake cable end - piece crimping may not conform so the handbrake cable may become detached.

Fix: Check crimping at cable end. Replace cable if not within tolerance.

1,768 vehicles

The anti-pinch or auto reverse function of the window regulator may not work correctly to ECE R21 requirements. So it is possible to trap items including fingers and limbs between the window and its closure.

Fix: Recall the vehicles that are likely to be affected to check and if necessary replace the window regulator motor.

1,291 vehicles

The anti-pinch or auto reverse function of the window regulator may not work correctly to ECE R21 requirements. So it is possible to trap items including fingers and limbs between the window and its closure.

Fix: Recall the vehicles that are likely to be affected to check and if necessary replace the window regulator motor.

1,291 vehicles

Because of a manufacturing error the nearside rear stub axle could start to develop cracks at the inner radius which could eventually lead to failure of the stub axle and difficulty in maintaining directional control.

Fix: Recall the vehicles that are likely to be affected to replace the rear axle.

246 vehicles · built 15 Dec 2009 to 22 Apr 2010

It has been found that some of the front seat mounting brackets have not been correctly fitted to the seats. The front seat mountings could fail if the fitting brackets have been incorrectly fitted. Vehicle control could be affected.

Fix: Recall the vehicles that are likely to be affected to check and where necessary fit new seat assemblies.

352 vehicles · built 15 Dec 2009 to 9 Jul 2010

It has been identified that in the unlikely event of a collision where there is a need for the deployment of the driver airbag it is a possible that the drivers airbag module may separate form its mounting on the steering wheel horn plate.

Fix: Recall all affected vehicles and replace the drivers airbag module.

8,926 vehicles

The fixing bolts of the front passenger seat rails to seat frame may fail and leave the seat insecure. In the event of an accident this could lessen the effectiveness of the seat belt.

Fix: Recall the vehicles that are likely to be affected to replace the front passenger seat rails to seat frame fixing bolts.

1,436 vehicles · built 1 Sep 2010 to 30 Sep 2010

The fixing bolts of the front passenger seat rails to seat frame may fail and leave the seat insecure. In the event of an accident this could lessen the effectiveness of the seat belt.

Fix: Recall the vehicles that are likely to be affected to replace the front passenger seat rails to seat frame fixing bolts.

1,436 vehicles · built 1 Sep 2010 to 30 Sep 2010

It has been identified that the welds to the left front suspension-strut turret many not be to specification. This could lead to detachment of the suspension-strut turret detachment and subsequent loss of control of the vehicle.

Fix: Recall all affected vehicles and apply additional weld seams to the turret.

15 vehicles · built 26 Jul 2006 to 27 Jul 2006

The mounting end of the handbrake cable may move in its support bracket. This might result in the loss of the handbrake function.

Fix: Recall affected vehicles to either have a washer installed or the replacement of the cable.

26,233 vehicles · built 1 Sep 2009 to 25 May 2010

The steering column intermediate shaft may have a loose press fit on the upper joint yoke. If left increased free play and a knocking noise will develop which if ignored could lead to loss of steering.

Fix: Recall the vehicles that are likely to be affected to fit a new intermediate steering shaft.

8,854 vehicles · built 16 Nov 2009 to 24 Mar 2010

The intermediate steering shaft may not be correctly coupled to the steering column which in certain driving conditions could result in disconnection and loss of steering control.

Fix: Recall the vehicles that are likely to be affected to inspect and where necessary reassemble the intermediate steering shaft to the steering column correctly.

4,084 vehicles · built 14 Jun 2006 to 31 Dec 2007

The welding to the right hand front single seat may not be to specification. In the event of an accident the right hand front seat may separate from the floor panel.

Fix: Recall the likely to be affected vehicles to add two welding seams on each rear bracket on the right hand front seat pedestal.

4,573 vehicles · built 22 Feb 2008 to 18 May 2009

The bolt securing the outer seat belt buckles may become loose on the 2nd and if fitted 3d row seats

Fix: Recall affected vehicles remove bolt remove washer clean and refit bolt applying thread lock

508 vehicles

It has been identified that the parking brake cable connector situated between the primary and intermediate parking brake cables may fracture. Should this occur the parking brake function would be lost.

Fix: Recalled vehicles will have the subject cable connector replaced.

45,330 vehicles · built 1 Jan 2006 to 30 Jun 2008

The laser cut split line of the passenger air-bag cover may not be present. In the case of an accident it is possible that the passenger air-bag may not deploy.

Fix: Recall the likely to be affected vehicles and replace the passenger air-bag module cover.

411 vehicles

There could be an unexpected loss of braking performance due to the ABS/ESP Modulator not being correctly filled with hydraulic oil at the factory.

Fix: Recall the vehicles that are likely to be affected to replace the ABS/ESP hydraulic modulator and control unit.

10 vehicles

It has been identified that on vehicles fitted with the Z16XEP engine the upper oil pressure switch might release oil onto the exhaust manifold heat protection shield which could result in self ignition.

Fix: Recalled vehicles will have the upper oil pressure switch replaced by a screw plug. Additionally a modified oil pressure switch will be fitted in a lower position.

33,639 vehicles · built 1 Mar 2003 to 31 Dec 2005

Following a small number of complaints of Vauxhall Vectra and Signum vehicles rolling away due to allegedly defective handbrakes. Vauxhall engineers in conjunction with consultants and other bodies have conducted rigorous testing and found that provided the handbrake is applied correctly without depressing the release button the handbrake is perfectly safe.

Fix: In line with it's priority of continuous improvement recalled vehicles will be fitted with a modified handbrake mechanism to reduce the possibility of a partial release.

236,284 vehicles · built 1 Jan 2002 to 31 Dec 2007

Following a small number of complaints of Vauxhall Vectra and Signum vehicles rolling away due to allegedly defective handbrakes. Vauxhall engineers in conjunction with consultants and other bodies have conducted rigorous testing and found that provided the handbrake is applied correctly without depressing the release button the handbrake is perfectly safe.

Fix: In line with it's priority of continuous improvement recalled vehicles will be fitted with a modified handbrake mechanism to reduce the possibility of a partial release.

236,284 vehicles · built 1 Jan 2002 to 31 Dec 2007

It has been identified that due to a manufacturing deviation the base material for the telescopic tube of the intermediate steering shaft may lack the required rigidity. This may lead to breakage of the shaft which in the worst case would lead to loss of steering control.

Fix: Recalled vehicles will be fitted with a quality assured steering shaft.

6,086 vehicles

It is possible for moisture to enter the ABS connector/control unit. This can cause the ABS system not to function correctly and in the worst case overheating which may lead to fire.

Fix: Recall the vehicles that are likely to be affected to check the ABS control unit fit a protective cover to the control unit and seal the earth point with wax.

345,634 vehicles · built 1 Jan 2003 to 21 Nov 2007

It is possible for moisture to enter the ABS connector/control unit. This can cause the ABS system not to function correctly and in the worst case overheating which may lead to fire.

Fix: Recall the vehicles that are likely to be affected to check the ABS control unit fit a protective cover to the control unit and seal the earth point with wax.

345,634 vehicles · built 1 Jan 2003 to 21 Nov 2007

It is possible for moisture to enter the ABS connector/control unit. This can cause the ABS system not to function correctly and in the worst case overheating which may lead to fire.

Fix: Recall the vehicles that are likely to be affected to check the ABS control unit fit a protective cover to the control unit and seal the earth point with wax.

345,634 vehicles · built 1 Jan 2003 to 21 Nov 2007

The retaining ring of the steering gear pinion might be out of it's retaining groove. In the worst case the steering gear pinion may lose engagement resulting in loss of steering control

Fix: Recall affected vehicles and replace steering gear assembly

557 vehicles

The retaining ring of the steering gear pinion might be out of it's retaining groove. In the worst case the steering gear pinion may lose engagement resulting in loss of steering control

Fix: Recall affected vehicles and replace steering gear assembly

557 vehicles · built 1 Aug 2007 to 1 Aug 2007

The retaining ring of the steering gear pinion might be out of it's retaining groove. In the worst case the steering gear pinion may lose engagement resulting in loss of steering control

Fix: Recall affected vehicles and replace steering gear assembly

557 vehicles

It has been identified that on a certain number of 2007 model year vehicles the front lower suspension control arms might fracture near the bushing due to a production deviation during the welding process. The control arm may then lack rigidity; which may impair driving stability. In the worst case the driver may loose control of the vehicle.

Fix: Subject vehicles will have the control arm welds checked and replaced as necessary.

26,502 vehicles

It has been identified that cracking of the parking brake actuating levers of the rear axle disc brake calipers may lead to loss of parking brake function.

Fix: Recalled vehicles will be inspected and affected parts replaced as necessary.

830 vehicles · built 1 Jan 2005 to 31 Dec 2005

In extreme driving conditions it is possible that the rear wheel/s may fracture.

Fix: Recall the vehicles that are likely to be affected and check that H.T. is stamped on the inside of one of the spokes. I there is no such marking the wheel/s must be replaced.

806 vehicles · built 1 Jan 2001 to 31 Dec 2002

In extreme driving conditions it is possible that the rear wheel/s may fracture.

Fix: Recall the vehicles that are likely to be affected and check that H.T. is stamped on the inside of one of the spokes. I there is no such marking the wheel/s must be replaced.

806 vehicles

It is possible that moisture may enter the heated washer nozzle housing and cause a short circuit of the heating elements. In the worse case a fire may ensue.

Fix: Recall the vehicles that are likely to be affected to disconnect the heated washer nozzle housings.

1,220 vehicles · built 1 Jan 2004 to 30 Dec 2006

In some circumstances there is a possibility that the side airbag may inadvertently deploy.

Fix: Recall the vehicles that are likely to be affected and fit additional springs to the front seats so that any electrostatic discharge will correctly earthed.

799 vehicles

It has been identified that during the manufacturing process the lock bar may not have been fitted to the belt retractor. In the worst case the restraint function of the rear seat centre belt might not operate correctly in the case of a frontal impact.

Fix: Recalled vehicles will have the rear centre seat belt inspected and replaced if necessary.

1,172 vehicles · built 1 Jan 2006 to 9 Mar 2006

It has been identified that on affected vehicle's the right hand front lower control arm guide joint may be incorrectly mounted. In the worst case the lower control arm could work loose separate from the steering knuckle and severely impair the control of the vehicle.

Fix: Recalled vehicles will have the guide joint checked for correct mounting and replaced if the mounting is found to be incorrect.

2,510 vehicles · built 1 Jan 2005 to 3 Feb 2006

It has been identified that the above vehicles could be affected by moisture ingress at the ABS connector. The moisture can enter through the ground wiring connection which can lead to the ABS not functioning correctly overheating within the connector and in extreme cases a fire.

Fix: Recalled vehicles will have the ABS harness plug checked for moisture ingress and where necessary the wiring harness and control unit will be replaced. In all other cases the ground cable will be secured against ingress of moisture by soldering the cable sockets and applying shrink tubes.

217,374 vehicles

It has been identified that the above vehicles could be affected by moisture ingress at the ABS connector. The moisture can enter through the ground wiring connection which can lead to the ABS not functioning correctly overheating within the connector and in extreme cases a fire.

Fix: Recalled vehicles will have the ABS harness plug checked for moisture ingress and where necessary the wiring harness and control unit will be replaced. In all other cases the ground cable will be secured against ingress of moisture by soldering the cable sockets and applying shrink tubes.

217,374 vehicles

It has been identified that the above vehicles could be affected by moisture ingress at the ABS connector. The moisture can enter through the ground wiring connection which can lead to the ABS not functioning correctly overheating within the connector and in extreme cases a fire.

Fix: Recalled vehicles will have the ABS harness plug checked for moisture ingress and where necessary the wiring harness and control unit will be replaced. In all other cases the ground cable will be secured against ingress of moisture by soldering the cable sockets and applying shrink tubes.

217,374 vehicles

The hardening process applied to the rear wheel bearing inner ring may be incorrect. There is a possibility that a rumbling noise may become apparent which if not checked could in extreme circumstances result in the detachment of the hub and severely impaired road holding/handling.

Fix: Recall the vehicles that are likely to be affected and check the date stamp on the rear wheel hubs. Where necessary replace the hub bearing assembly.

783 vehicles

The hardening process applied to the rear wheel bearing inner ring may be incorrect. There is a possibility that a rumbling noise may become apparent which if not checked could in extreme circumstances result in the detachment of the hub and severely impaired road holding/handling.

Fix: Recall the vehicles that are likely to be affected and check the date stamp on the rear wheel hubs. Where necessary replace the hub bearing assembly.

783 vehicles

It has been identified that during production an incorrect torque was applied to the trailer hitch fitting bolts.

Fix: Recalled vehicles will have the trailer hitch bolts replaced and tightened to the correct torque.

22 vehicles

Constant quality controls have revealed that on some vehicles the passenger side airbag mounting fixing screws were not torqued to the correct specification. This could result in the airbag unit becoming loose.

Fix: Recall the vehicles that are likely to be affected and tighten the two airbag retaining screws

246 vehicles

As a result of an incorrect steering gear and steering knucle combination being fitted during manufacture the front tyres may contact the lower front suspension arms when the steering is turned on to a full lock.

Fix: Recall the vehicles that are likely to be affected and replace both the steering knucles. Additionally the lower suspension arms and tyres will be checked for damage.

530 vehicles · built 1 Dec 2004 to 1 Dec 2004

It has been identified that the Isofix connector which is part of the Opel/Vauxhall accessory child seat with transponder might break. This is as the result of the material not being to specification.

Fix: End users will be contacted and the seat replaced.

19 vehicles

It is possible that the auxiliary heater harness connection could over heat or burn due to oxidization. In extreme cases it is possible that this could result in a thermal incident.

Fix: Recall the affected vehicles and install heat shrink sleeves to the wining.

2,593 vehicles · built 1 Oct 1992 to 1 Oct 1999

The possibility exists that the rear exhaust pipe can move backwards and slip off the front pipe. With the possibility that under body components may become damaged.

Fix: Recall affected vehicles check likely to be affected under body areas and install a new exhaust clamp.

10,470 vehicles · built 5 Aug 2004 to 5 Aug 2004

The possibility exists that the rear exhaust pipe can move backwards and slip off the front pipe. With the possibility that under body components may become damaged.

Fix: Recall affected vehicles check likely to be affected under body areas and install a new exhaust clamp.

10,470 vehicles · built 5 Apr 2004 to 5 Apr 2004

Steering wheel mounting may not have been tightened to specification. This may lead to the steering wheel vibrating so impairing control of the vehicle.

Fix: Recall the vehicles that are likely to be affected replace the steering wheel and fix with a new bolt to a new tightening specification.

2,947 vehicles · built 5 Sep 2004 to 5 Sep 2004

Due to moisture and dust ingress the inner throttle cable may stick.

Fix: Recall affected vehicles and replace the throttle cable end cover or the cable assembly as necessary.

1,047 vehicles · built 1 Jun 1992 to 1 Jun 1995

Fixing bolts of the rear seat belt on the height adjuster C pillar and body sill may not have been torqued according to specification

Fix: Recall likely to be affected vehicles check torque rear seat belts and tighten to specification.

136 vehicles · built 1 Apr 2004 to 1 Apr 2004

The steering wheel centre screw may not have been tightened correctly.

Fix: Replace the centre torx screw and tighten to the specified torque.

144 vehicles

The steering wheel centre screw may not have been tightened correctly.

Fix: Replace the centre torx screw and tighten to the specified torque.

144 vehicles

Power steering gear lower bearing may separate causing intermittent increased steering effort when turning.

Fix: Check lower bearing and where necessary install a new bearing or power steering gear.

2,436 vehicles

A brake pedal linkage retaining clip may become detached after high mileage. Although no incidents have been reported in the worst case a pedal link could become detached and render the footbrake ineffective.

Fix: Fit modified brake pedal linkage retaining clips.

1,148 vehicles

Potential soft brake pedal and reduced brake performance due to water induced corrosion of the brake master cylinder and consequential fluid leakage.

Fix: Replace the brake master cylinder and refill brake system with fresh fluid.

826 vehicles

There is a risk that the drivers air bag can crack over time and subsequently may not properly inflate under deployment.

Fix: Replace drivers air bag.

729 vehicles

There is a slight chance that one or more of the tapped holes for the four bolts securing the two halves of the brake caliper body together has not been threaded through the full depth of the hole. The structural integrity of any such caliper may be compromised with the risk of fatigue failure of the caliper occurring after an extended period.

Fix: Check the caliper tapped holes. If any incomplete threading is found the brake caliper is to be replaced.

31 vehicles

As a result of a production process concern a specific batch of brake calliper pistons may release hot hydrogen gas into the braking system fluid.

Fix: Affected vehicles are being recalled for on the brake calliper batch numbers. Vehicle equipped with calliper units from the affected batch will have these replaced with quality assured examples.

2,437 vehicles

As a result of a production process concern a specific batch of brake calliper pistons may release hot hydrogen gas into the braking system fluid.

Fix: Affected vehicles are being recalled for on the brake calliper batch numbers. Vehicle equipped with calliper units from the affected batch will have these replaced with quality assured examples.

2,437 vehicles

The driver and front passenger seat longtitudinal adjuster latch spring may weaken and fail to lock the seat in the selected position. This could affect the drivers control of the vehicle and/or passenger safety.

Fix: Recall affected vehicles and check the effectiveness of the adjuster latch spring. Fit a new seat base in cases where the spring is found to be defective.

8,674 vehicles

The driver and front passenger seat longtitudinal adjuster latch spring may weaken and fail to lock the seat in the selected position. This could affect the drivers control of the vehicle and/or passenger safety.

Fix: Recall affected vehicles and check the effectiveness of the adjuster latch spring. Fit a new seat base in cases where the spring is found to be defective.

8,674 vehicles

Child seat safety cradle with transponder may not interact as intended with front passenger smart Airbag deactivation function. Software concern with control unit.

Fix: Replace front Airbag control unit with a quality assured item.

128 vehicles

Child seat safety cradle with transponder may not interact as intended with front passenger smart Airbag deactivation function. Software concern with control unit.

Fix: Replace front Airbag control unit with a quality assured item.

128 vehicles

Driver and front passenger seat belt latching mechanism may separate when loaded in a frontal impact.

Fix: Recall affected vehicles and fit quality assured seat belt buckles.

116,378 vehicles · built 1 Jan 1999 to 31 Dec 2000

Driver and front passenger seat adjuster rails may fracture and cause seat to become insecure.

Fix: Recall affected vehicles and fit reinforcing plates to the seat runners. Fit new runners if the original ones are fractured.

586,554 vehicles · built 1 Jan 1993 to 31 Dec 1999

Driver and front passenger seat belt latching mechanism may separate when loaded in a frontal impact.

Fix: Recall affected vehicles and fit quality assured seat belt buckles.

116,378 vehicles · built 1 Jan 1999 to 31 Dec 2000

Driver and front passenger seat adjuster rails may fracture and cause seat to become insecure.

Fix: Recall affected vehicles and fit reinforcing plates to the seat runners. Fit new runners if the original ones are fractured.

586,554 vehicles · built 1 Jan 1993 to 31 Dec 1999

Driver and front passenger seat belt latching mechanism may separate when loaded in a frontal impact.

Fix: Recall affected vehicles and fit quality assured seat belt buckles.

116,378 vehicles · built 1 Jan 1999 to 31 Dec 2000

Driver and front passenger seat adjuster rails may fracture and cause seat to become insecure.

Fix: Recall affected vehicles and fit reinforcing plates to the seat runners. Fit new runners if the original ones are fractured.

586,554 vehicles · built 1 Jan 1993 to 31 Dec 1999

Defective crimping of fuel return hose to metal pipe connector may result in a fuel leak.

Fix: Recall affected vehicles and fit a quality assured replacement pipe.

605 vehicles · built 1 Jan 2000 to 31 Dec 2001

Front driver and co-driver seat locking mechanism may become inoperative. Seats may become insecure.

Fix: Recall affected vehicles and replace easy entry spring housing on driver and co-driver seat frame.

3,009 vehicles · built 1 Jan 1998 to 31 Dec 1998

Front driver and co-driver seat locking mechanism may become inoperative. Seats may become insecure.

Fix: Recall affected vehicles and replace easy entry spring housing on driver and co-driver seat frame.

3,009 vehicles · built 1 Jan 1998 to 31 Dec 1998

The diesel engine fuel feed and return metal pipes may fracture and leak if the vehicle is involved in a frontal collision.

Fix: Recall affected vehicles and replace the original fuel pipes with ones of improved specification.

262 vehicles · built 1 Jan 2000 to 31 Dec 2000

Vauxhall in conjunction with DETR and VI have agreed to conduct a Customer Care Initiative whereby drivers of old style Astra F models will be advised that brake fluid is a service item due to its' hygroscopic (water absorbing) tendency.

Fix: Customers will be offered a free inspection and a special promotion brake fluid change should the fluid be found to be outside the manufacturers specified limits. A minor modification to the vehicle bonnet will also be carried out to eliminate the remote possibility of water entering the engine compartment along the bulkhead and contaminating the brake fluid. It should be noted that this Customer Care Initiative is being recorded under the Code of Practice.

636,066 vehicles · built 1 Aug 1991 to 28 Feb 1999

There is a possibility that the brake servo valve may not function correctly resulting in loss of servo assistance to the braking system.

Fix: Recall affected vehicles for the inspection and possible replacement of the brake servo valve.

1,139 vehicles · built 1 Jan 2000 to 31 Dec 2000

There is a possibility that the brake servo valve may not function correctly resulting in loss of servo assistance to the braking system.

Fix: Recall affected vehicles for the inspection and possible replacement of the brake servo valve.

1,139 vehicles · built 1 Jan 2000 to 31 Dec 2000

The brake vacuum pump fitted to the F8Q diesel engine can leak with the potential to allow oil to enter the brake servo with the consequence that a sudden loss of servo assistance and reduction of braking efficiency could occur.

Fix: All potentially affected vehicles will be recalled and the make of the vacuum pump checked. Should this be found to be of Magnetti Marelli manufacture the pump will be changed for a quality assured unit. In addition the servo and associated vacuum pipe will be examined for oil ingress and replaced where necessary.

573 vehicles · built 1 Apr 1997 to 31 Dec 1998

Under certain conditions the engine wiring harness may touch the bonnet hinge. With prolonged chafing this may lead to a possible electrical short circuit and if not dealt with eventual combustion.

Fix: Affected vehicles are being recalled to have the engine wiring harness re-routed and secured clear of the bonnet hinge.

26,000 vehicles · built 1 Jan 1993 to 31 Dec 1996

Under certain conditions the engine wiring harness may touch the bonnet hinge. With prolonged chafing this may lead to a possible electrical short circuit and if not dealt with eventual combustion.

Fix: Affected vehicles are being recalled to have the engine wiring harness re-routed and secured clear of the bonnet hinge.

26,000 vehicles · built 1 Jan 1993 to 31 Dec 1996

Under certain conditions the engine wiring harness may touch the bonnet hinge. With prolonged chafing this may lead to a possible electrical short circuit and if not dealt with eventual combustion.

Fix: Affected vehicles are being recalled to have the engine wiring harness re-routed and secured clear of the bonnet hinge.

26,000 vehicles · built 1 Jan 1993 to 31 Dec 1996

Insufficient diameter of the handbrake cable may cause the handbrake to fail prematurely.

Fix: Affected vehicles are being recalled to have the handbrake cable replaced with a modified larger diameter version.

195,000 vehicles · built 1 Jan 1995 to 31 Dec 1998

Insufficient diameter of the handbrake cable may cause the handbrake to fail prematurely.

Fix: Affected vehicles are being recalled to have the handbrake cable replaced with a modified larger diameter version.

195,000 vehicles · built 1 Jan 1995 to 31 Dec 1998

In a small number of cases the fuel supply and/or return pipes may detach from their connection at the fuel tank.

Fix: The affected vehicles are being recalled to have the security of the supply and return pipes checked. Where any of the pipes is found to be insecure the securing clip and if necessary the tank sender unit will be replaced.

39,601 vehicles · built 1 Jan 1996 to 21 May 1996

In a small number of cases the fuel supply and/or return pipes may detach from their connection at the fuel tank.

Fix: The affected vehicles are being recalled to have the security of the supply and return pipes checked. Where any of the pipes is found to be insecure the securing clip and if necessary the tank sender unit will be replaced.

39,601 vehicles · built 1 Jan 1996 to 21 May 1996

In the event of an exhaust tail pipe fracture an unacceptably high level of heat radiation may occur in the area surrounding the fuel tank.

Fix: Recall the affected vehicles for the installation of a protective shield over the fuel tank.

40,042 vehicles

1) During refuelling the flow of fuel can cause static electricity to build up in the tank filler neck with the possibility of static sparking. 2) On some vehicles an electrical connector plug in the air bag system may not be correctly possible

Fix: A) The fitting of a metal earthing clamp to the lower end of the metal ring for the fuel filler cap to ensure a conductive connection between the filler neck and the vehicle body. B) Checking that in potentially affected vehicles the subject elect

601,131 vehicles · built 1 Aug 1991 to 28 Feb 1995

1) During refuelling the flow of fuel can cause static electricity to build up in the tank filler neck with the possibility of static sparking. 2) On some vehicles an electrical connector plug in the air bag system may not be correctly possible

Fix: A) The fitting of a metal earthing clamp to the lower end of the metal ring for the fuel filler cap to ensure a conductive connection between the filler neck and the vehicle body. B) Checking that in potentially affected vehicles the subject elect

601,131 vehicles · built 1 Aug 1991 to 28 Feb 1995

1) During refuelling the flow of fuel can cause static electricity to build up in the tank filler neck with the possibility of static sparking. 2) On some vehicles an electrical connector plug in the air bag system may not be correctly possible

Fix: A) The fitting of a metal earthing clamp to the lower end of the metal ring for the fuel filler cap to ensure a conductive connection between the filler neck and the vehicle body. B) Checking that in potentially affected vehicles the subject elect

601,131 vehicles · built 1 Aug 1991 to 28 Feb 1995

1) During refuelling the flow of fuel can cause static electricity to build up in the tank filler neck with the possibility of static sparking. 2) On some vehicles an electrical connector plug in the air bag system may not be correctly possible

Fix: A) The fitting of a metal earthing clamp to the lower end of the metal ring for the fuel filler cap to ensure a conductive connection between the filler neck and the vehicle body. B) Checking that in potentially affected vehicles the subject elect

601,131 vehicles · built 1 Aug 1991 to 28 Feb 1995

1) During refuelling the flow of fuel can cause static electricity to build up in the tank filler neck with the possibility of static sparking. 2) On some vehicles an electrical connector plug in the air bag system may not be correctly possible

Fix: A) The fitting of a metal earthing clamp to the lower end of the metal ring for the fuel filler cap to ensure a conductive connection between the filler neck and the vehicle body. B) Checking that in potentially affected vehicles the subject elect

601,131 vehicles

As a result of engine movement a wiring harness may chafe on a steel brake pipe adjacent to the brake master cylinder. This could cause short circuiting and possible loss of braking efficiency should the brake fluid temperature rise as a result.

Fix: Recall the affected vehicles for the fitment of a modified clip to the wiring harness. Additionally the harness will be sheathed for additional protection in the area adjacent to the brake pipe.

32,770 vehicles · built 1 Mar 1992 to 31 Mar 1994

The engine wiring harness may chafe on the power steering pump pulley resulting in a possible fire hazard.

Fix: Recall the affected vehicles and secure the wiring harness with cable ties as per the manufacturers instructions. At the same time the wiring will be checked for damage and where this has occurred it will be rectified as required.

14,452 vehicles · built 4 Sep 1992 to 29 Jan 1993

Under certain conditions the alternator feed wire/terminal may contact the clutch cable and the instrument panel harness may chafe against the steering column. Either of these concerns could lead to short circuiting and.

Fix: Recall the affected vehicles reposition the alternator terminal and secure the wiring harnesses in the bulkhead area away from moving parts.

12,000 vehicles · built 1 Jan 1993 to 31 Dec 1993

Cracking may occur in the steering drop arm or idler arm and bracket assembly which if not detected could ultimately affect steering control.

Fix: Recall the affected vehicles for examination of the subject components. Any arms or brackets identified as belonging to the affected batches will be replaced with quality assured examples.

4,489 vehicles · built 1 Aug 1992 to 30 Nov 1992

Cracking may occur in the steering drop arm or idler arm and bracket assembly which if not detected could ultimately affect steering control.

Fix: Recall the affected vehicles for examination of the subject components. Any arms or brackets identified as belonging to the affected batches will be replaced with quality assured examples.

4,489 vehicles · built 1 Aug 1992 to 30 Nov 1992

Cracking may occur in the steering drop arm or idler arm and bracket assembly which if not detected could ultimately affect steering control.

Fix: Recall the affected vehicles for examination of the subject components. Any arms or brackets identified as belonging to the affected batches will be replaced with quality assured examples.

4,489 vehicles · built 1 Aug 1992 to 30 Nov 1992

Certain vehicles within the chassis range specified may have been fitted with examples of a batch of Dunlop tyres which are the subject of a recall. The tyres were affected by a contaminant during manufacture which could cause loss of adhesion between

Fix: Recall the affected vehicles for examination of the tyres. Where any tyres from the affected batch are found they will be replaced.

5,966 vehicles · built 1 Nov 1992 to 30 Nov 1992

The seam weld joining the wheel disc to the wheel rim may lack penetration resulting in failure of the weld and eventual detachment of the road wheel.

Fix: Recall the affected vehicles and replace the road wheels with quality assured examples.

1,059 vehicles · built 1 Aug 1991 to 1 Jun 1992