Citroen Relay recalls

On affected vehicles the Body Control Module is not correctly configured to detect a failure in the indicator lamps. As a result if a turn indicator bulb fails it's not detected and the indicator warning does not activate.

Fix: Update the vehicle configuration and the Secure Gateway Electronic Control Unit.

2,193 vehicles · built 2 Feb 2024 to 13 Nov 2025

Affected vehicles have a smart tachograph fitted that may not comply with regulatory requirements.

Fix: Replace the Tachograph Sensor Antenna(s) and adding Wiring Harnesses if necessary.

18 vehicles · built 27 Sep 2024 to 4 Dec 2025

Affected vehicles may have been fitted with fuel return pipes not according to specification which can lead to a fuel leak.

Fix: Check the fuel return pipes and replace if necessary.

557 vehicles · built 7 Jan 2025 to 22 Jul 2025

Affected vehicles may have an incorrect speed limitation value displayed on the instrument cluster due to a wrong configuration.

Fix: Update the configuration in the body control module.

13 vehicles · built 3 Dec 2024 to 11 Feb 2025

On affected vehicles the Automatic Emergency Brake (AEB) function may remain deactivated in a specific use case.

Fix: Update the Front Camera software to ensure correct activation / deactivation of the AEB system.

797 vehicles · built 17 Sep 2024 to 11 Mar 2025

On affected vehicles a low AdBlue level message may not be displayed on the Instrument Panel Cluster. This could lead to the possibility of not being able to start the vehicle due to an empty AdBlue tank.

Fix: Update the Instrument Panel Cluster software.

11 vehicles · built 28 Jun 2021 to 21 Mar 2024

On affected vehicles the traffic sign recognition function does not meet regulatory requirements. After de-activation it will remain de-activated even after vehicle restart.

Fix: Update the radio software via over-the-Air.

8 vehicles · built 13 Dec 2023 to 25 May 2024

On affected vehicles an incorrect radio may be fitted that does not provide rear view camera functionality to comply with regulatory requirements.

Fix: On the affected vehicles the radio will be replaced

7 vehicles · built 4 Apr 2024 to 17 Jul 2024

Affected vehicles may have been fitted with a metal Manufacturer plate located in the engine compartment that shows the wrong weight values. This can lead to a non-compliance to regulatory requirements.

Fix: Check and replace the metal Manufacturer plate.

11 vehicles · built 26 Mar 2024 to 18 Jul 2024

Some vehicles have been produced without the required earthing connection on the protective cover of the high voltage connection box.

Fix: Check the affected vehicles and add the missing earthing connection wire between the box and the body if necessary.

12 vehicles · built 8 Sep 2020 to 19 Oct 2021

The seat fastening to the anchor plate is not correct to specification.�

Fix: Replace�the swivel plates onto which the front seats are anchored.�

11 vehicles · built 10 Feb 2021 to 19 Apr 2021

Affected vehicles are not fully compliant to European regulation (165/2014 + EU 799/2016) covering the �Smart Tachograph� requirements.

Fix: Replacing the tachograph gearbox and on certain vehicles the windscreen depending on the specification of the vehicle.

1 vehicle · built 3 Jan 2019 to 14 Nov 2019

The front hub assembly fixing on to the front suspension damper may not be correct to specification.

Fix: Check the front hub assembly and replace if required.

1,955 vehicles · built 2 May 2019 to 12 Jul 2019

The brake pipe fixings may not conform to specification

Fix: Checking and repairing these fixings and replacing any damaged pipes as necessary

16,144 vehicles · built 5 Jul 2016 to 17 Jun 2019

On the affected vehicles the tightening of a sealing plug on the engine oil gallery may not be correct to specification.This could lead over time to an oil leak which in rare cases could result in oil leaking on to the road.

Fix: The remedy consists of tightening the engine oil gallery sealing plug to the correct torque.

37 vehicles · built 3 May 2018 to 1 Jun 2018

The electrical switch of the steering lock may not conform to specification. This could cause the intermittent unwanted switching off of information displays on the instrument panel.

Fix: Recall the vehicles that are likely to be affected and replace the ignition switch.

5,641 vehicles · built 30 Sep 2014 to 16 Jun 2015

An internal component of the injector may not be to specification which could reduce the fuel pressure in the injection system. The concern can prevent the engine starting and/or cause the engine to stall.

Fix: Recall the vehicles that are likely to be affected and check the identification number of the engine injectors. Where necessary replace the injectors.

1,145 vehicles · built 11 Sep 2014 to 13 Nov 2014

The fixture of the handbrake cable stop support may not have been produced to the correct specification. If not rectified this could cause a reduction in hand brake efficiency.

Fix: Recall all affected vehicles and install strengthening for the handbrake cable stop support under the vehicle.

7 vehicles · built 30 May 2012 to 31 May 2012

The spare wheel winch may fail and not secure the spare wheel to the vehicle so allowing it to detach from the vehicle.

Fix: Recall all affected vehicles and replace the spare wheel winch.

• RELAY: 13,095 vehicles · built 18 Jul 2006 to 1 Apr 2009
• RELAY: 13,095 vehicles · built 18 Jul 2006 to 21 Apr 2010

It has been identified that the check valve within the brake assistance vacuum pump may suffer from a non-conformity which in time may reduce the braking assistance.

Fix: Recalled vehicles as a preventative measure will have the subject valve replaced. At the same time certain vehicles will also have the air dosing unit replaced.

307 vehicles · built 16 May 2006 to 22 Dec 2006

It has been identified that; with the engine switched off the side indicator repeaters do not operate when the parking lights are on.

Fix: Recalled vehicles will have the relevant operating software upgraded.

67 vehicles · built 27 Nov 2007 to 30 Nov 2007

It has been identified that a problem may arise with the steering mechanism which can result in hardness whilst manoeuvring.

Fix: Recalled vehicles will have the steering mechanism checked and lubricated. The mechanism will be replaced if found to be damaged. At the same time certain vehicles will have key components reinforced against the ingress of water. Thus preventing operating faults in the long term.

2,779 vehicles · built 18 Jul 2006 to 8 Mar 2007

Braking maybe impaired due to some brake pipes not being manufactured to conformity.

Fix: Recall the vehicles that are likely to be affected to check the serial numbers of the brake pipes and to replace the brake pipes where necessary.

456 vehicles · built 16 Oct 2007 to 15 Nov 2007

Braking assistance could be adversely by freezing of moisture that may accumulate in the vacuum circuit.

Fix: Recall the vehicles that may be affected and fit a separate air vent complete with filter to each electro valve fitted to the vacuum circuit.

18,387 vehicles · built 26 Mar 2002 to 27 Jul 2005

The brake hoses may chafe on the wheel aches and in extreme cases cause a brake fluid leak. The driver will be informed of the defect by the illumination of a warning lamp on the dashboard. If ignored then this will result in longer than expected stopping distances.

Fix: Recall the vehicles that are likely to be affected and visually inspect the front brake hoses reinforcement and protection. The brake hoses if worn will be replaced.

9,945 vehicles · built 3 Sep 2002 to 12 Sep 2003

The accelerator pedal can become jammed in the fully open position.

Fix: Replace the accelerator pedal stop with a modified version.

10,473 vehicles · built 1 Mar 2002 to 1 Feb 2004

The handbrake adjustment system may be unreliable which will reduce its efficiency under certain conditions.

Fix: Check adjust and/or replace the brake shoe mechanisms.

4,448 vehicles · built 1 Mar 2002 to 30 Sep 2003

Inadequate protection of the heater blower wiring harness may result in chafing damage leading to a short circuit and risk of fire.

Fix: Check for correct routing of the blower wiring harness and fit a protective sleeve.

3,083 vehicles · built 31 May 2002 to 30 Jan 2002

The rear suspension cross member may have been cut in production. This could eventually result in failure of the cross member and cause loss of control of the vehicle.

Fix: Replace any rear suspension cross member found to be cut.

42 vehicles · built 1 Sep 2002 to 30 Sep 2002

There is a possibility that the parking brake cable may not be to the correct specification and could break at the rear section resulting in loss of parking brake.

Fix: Recall affected vehicles and replace parking brake cable.

171 vehicles · built 1 Nov 2001 to 31 Dec 2001

Fuel tank rear mountings may not adequately secure the tank with a risk of possible disengagement.

Fix: Recall affected vehicles and fit additional bolts or reinforcement plates to rear tank mountings depending on original build configuration.

2,313 vehicles · built 1 Jul 1999 to 31 Mar 2000