Peugeot 807 recalls

The fuel heating device integrated in to the diesel fuel filter cover may be defective and allow heat to build up within the electrical supply connector causing the cover to distort and air to enter the fuel circuit. This could make the vehicles difficult to start and a warning light will be illuminated on the dash board. The engine could be difficult or not possible to start. In the worst cases a diesel fuel leak could eventually appear.

Fix: Recall the vehicles that are likely to be affected and replace the fuel heater cover. Additionally the electrical connector will be inspected and where necessary replaced.

12,833 vehicles · built 3 Sep 2012 to 19 Dec 2014

The steering column link bolt which retains the steering wheel to the steering column may not have been tighten to the correct specification. This can result in a gradual increase in movement between the steering wheel and shaft with an associated rattle. This should identify the issue to the driver however if the driver does not heed this warning then the steering control of the vehicle could be reduced.

Fix: Recall all affected vehicles to check and if required re-torque the steering column link bolt.

71 vehicles · built 14 Jun 2011 to 25 Nov 2011

Some tyres may have suffered superficial damage when the vehicle was being transported. The front Left hand tyre may have localised damage on the tread or the inner side. The tyre may rip and deflate.

Fix: Carry out a visual check of the condition of the tyre in the affected areas and replace the tyre if necessary.

14 vehicles · built 30 Jan 2012 to 30 Jan 2012

It is possible that the wiring harness for the power assisted steering motor may come in contact with other components in the engine bay. Should this occur then it is possible that the power steering assistance on this large vehicle may become affected.

Fix: Recall affected vehicles and fit protection to the wiring harness.

1,577 vehicles · built 1 Feb 2010 to 7 Feb 2011

In very rare circumstances the vacuum pump one way valve may not function correctly which could affect the level of braking assistance.

Fix: Recall the vehicles that are likely to be affected to replace the brake vacuum pump one way valve.

24,220 vehicles · built 15 Dec 2006 to 31 Mar 2009

It has been identified that the position of the exterior lighting control ring may not be detected by the lighting management system and the lights may switch off without warning.

Fix: Recalled vehicles will have the lighting management software updated.

2,903 vehicles · built 6 Jul 2007 to 7 Mar 2008

The threaded portion of the brake linkage rod in the brake control system may not be to conformity. This could result in a reduction of braking efficiency.

Fix: Recall affected vehicles to check rod and replace if found not to meet conformity.

386 vehicles · built 24 Feb 2010 to 3 Jun 2010

The lighting management system may incorrectly detect the position of the exterior lighting control switch. This may cause the exterior light to switch off without warning.

Fix: Recall all affected vehicles and install a new version of the exterior lighting management software to the vehicle.

635 vehicles · built 1 Jul 2007 to 27 Mar 2008

It has been identified that a slight amount of play in the diesel fuel return pipe mountings on certain vehicles may over time lead to abrasion and wear of the pipe.

Fix: Recalled vehicles will have the subject clips checked and the pipe secured.

2,323 vehicles

It has been identified that on the specified vehicles a fault may develop with the brake vacuum pump. This can result in hardening of the brake pedal with an attendant loss of braking efficiency.

Fix: Recalled vehicles will have the vacuum pump replaced.

19,867 vehicles · built 1 Jul 2005 to 31 Dec 2006

The seat belt locking action may not be as fast as it is designed to be.

Fix: Recall the vehicles that may be affected to check the date of manufacture of the seat belts and where necessary replace the seat belts.

37 vehicles · built 16 Dec 2005 to 19 Dec 2005

Braking assistance could be adversely by freezing of moisture that may accumulate in the vacuum circuit.

Fix: Recall the vehicles that may be affected and fit a separate air vent complete with filter to each electro valve fitted to the vacuum circuit.

16,530 vehicles

Due to a potential fault in the engine management system an internal engine fuel leak via the injectors may occur following switching off. This would result in the engine failing to restart due to excess fuel being present in the inlet manifold or cylinders.

Fix: To address the issue recalled vehicles will receive an engine management download.

4,338 vehicles

Under certain circumstances a brake pipe may chafe on the turbo charger air intake securing clip. In extreme situations the wear caused could lead to leakage within a brake circuit and the illumination of the red brake warning light.

Fix: Recalled vehicles will be checked for the chafe condition and if necessary the turbo air intake securing clip will be relocated. The affected brake pipe will also be changed if it displays any sign of wear.

1,898 vehicles

Some cases have been found where inadequate drainage of water condensing from the air conditioning system has caused water to run under the carpet. This in turn may lead to the airbag warning light coming on or in extreme cases lead to airbag systems malfunctioning.

Fix: Recall the vehicles that are likely to be affected for modification of the drainage tube and the anti return valve.

6,304 vehicles

The original engine software may cause erratic operation of the motorised throttle body. This could in rare extreme cases cause the throttle stop to break. This will cause the engine to revert to limp home mode which possible may cause a reduction in braking assistance.

Fix: Install updated software in the engine ECU.

8,599 vehicles

There is a possibility of defective components in the heater blower which could cause a short circuit and loss of ventilation of the passenger compartment and in an extreme condition could set fire to the wiring harness.

Fix: Recall affected vehicles and replace heater blower module

168 vehicles · built 10 May 2001 to 10 Jan 2003

There is a possibility that water may ingress into the airbag electronic control unit (ECU) compartment. This may cause premature deployment of the airbag.

Fix: Seal the airbag ECU compartment.

326 vehicles · built 19 Jan 2001 to 3 Dec 2002

There is a possibility that the electric sliding doors may open whilst the vehicle is in motion.

Fix: Fit a replacement electronic control unit to the door.

326 vehicles · built 19 Jan 2001 to 3 Dec 2002

Rear bench seat in third row may not lock in place and tip forward during harsh deceleration

Fix: Recall affected vehicles and modify routing of check strap.

3 vehicles · built 6 Dec 2002 to 30 Jan 2003