Peugeot Traveller recalls

Affected vehicle may face a black screen on the Instrument Panel Cluster with several functions not available to view.

Fix: Update the In-Vehicle-Infotainment software via Over-the-Air.

1 vehicle · built 13 Dec 2023 to 8 Jul 2025

On affected vehicles there is an issue with the Engine Control Module (ECM) calibration which may lead to non-compliance with regulatory emission requirements.

Fix: Update the ECM calibration.

54 vehicles · built 17 May 2022 to 29 Jan 2024

Affected vehicles may have been equipped with rear brake discs out of specification. These brake discs have insufficient contact with the wheel hub resulting in abnormal stress concentration.

Fix: Check the rear brake discs and replace them and the brake pads if necessary.

2 vehicles · built 24 Jan 2024 to 24 Jan 2024

Vehicles may be affected by incorrect performance of the On-Board-Diagnostics related to Selective Catalytic Reduction system and/or Diesel Particle Filter. The Malfunction Indicator Light (MIL) may not illuminate in the event of a malfunction and therefore does not comply with emission regulations.

Fix: Update the Engine Control Unit software to ensure compliance to regulations.

6,298 vehicles · built 2 Jun 2017 to 11 Oct 2021

Vehicles may be affected by premature wearing of the camshaft drive chain leading to abnormal noise or to a breakage of the chain in the worst case.

Fix: Update the software to improve oil pressure and reduce wear. Check the engine noise and replace the chain if required. If no problem found change the oil to one with higher viscosity and special anti-wear additives.

338 vehicles · built 18 Jan 2018 to 3 May 2022

Affected vehicles may face an error in the Battery Monitoring Unit software.

Fix: Update the Battery Monitoring Unit software.

14 vehicles · built 1 Jul 2022 to 30 Nov 2022

On affected vehicles there may be insufficient fixing on the 1st and/or 2nd row of seats that could potentially allow seat movement in the event of a collision

Fix: On the affected vehicles seat fixings will be reworked

22 vehicles · built 28 Aug 2024 to 8 Oct 2024

On affected vehicles the AC compressor stator wiring could develop a fault leading to current loss inside the AC compressor that could result in a vehicle powertrain shutdown when driving.�

Fix: Reprogram the Powertrain Diagnosis ECU with updated software.

29,537 vehicles · built 10 Mar 2020 to 7 Dec 2022

Affected vehicles may have a steering tie rod/track rod end nut that has not been tightened to the correct torque.

Fix: Replace the steering tie rod/track rod end nut and tighten to the correct torque.

4 vehicles · built 12 Sep 2022 to 17 Nov 2022

Some vehicles may have been equipped with an incorrectly positioned fuel pipe.�

Fix: Check fuel pipe positioning correct if necessary and fit protective sleeve.�

2,231 vehicles · built 30 Jan 2020 to 21 Jan 2022

On the affected vehicles equipped with a manual handbrake the efficiency of the handbrake and service brake may be compromised.�

Fix: Check the rear brake caliper references and replace as necessary.�

57 vehicles · built 20 Jan 2022 to 28 Jan 2022

The High Voltage Harness might not be to the correct specification.

Fix: Check the harness conformity and replace it if necessary

16 vehicles · built 17 Mar 2022 to 30 Apr 2022

Affected vehicles may have been equipped with headrests on the front modular seat which do not conform to the design specification.

Fix: Check the conformity of the front headrests (presence of the catch); in cases of non-conformity the front headrests will be replaced.

708 vehicles · built 16 Nov 2021 to 16 Dec 2021

The rear window electrical harness could become displaced from its original position and present a potential thermal issue.

Fix: Check the routing of harness and replace the electrical harness if necessary. Add a fastening clip to ensure that the electrical harness will be maintained in its normal position.

51 vehicles · built 16 Nov 2015 to 13 Oct 2016

The rear spring centraliser might be welded incorrectly.

Fix: Add 3 weld spots to the rear spring centralisers

2 vehicles · built 15 Apr 2021 to 29 Apr 2021

A single wheel bolt on both right-hand wheels may not be tightened to the correct tightening torque.

Fix: Check and if necessary replace wheel bolts and any other associated parts if consequential damage has occurred.

4 vehicles · built 24 Sep 2020 to 11 Nov 2020

A single wheel bolt on both left-hand wheels may not be tightened to the correct tightening torque.

Fix: Check and if necessary replace wheel bolts and any other associated parts if consequential damage has occurred.

11 vehicles · built 24 Sep 2020 to 11 Nov 2020

A rear seat longitudinal adjustment lever may not lock properly.

Fix: Check affected seat frames and replacing them if necessary.

11 vehicles · built 19 Nov 2019 to 27 Feb 2020

Affected Vehicles have been fitted with an exhaust system which is not correct to specification

Fix: Install correct exhaust system catalytic convertor.

1 vehicle · built 1 Aug 2019 to 31 Jan 2020

A non-conformity of the rear brake callipers could reduce the efficiency of the parking brake.

Fix: Check and if necessary replace the callipers

134 vehicles · built 22 Mar 2019 to 15 Apr 2019

The tightening of the seat belt fixings and of certain earth cables may not conform to specification

Fix: Tightening of the seat belt fixings and of certain earth cables.

127 vehicles · built 17 Dec 2018 to 26 Apr 2019

The tightening of some rear suspension fixings may not be correct to specification.

Fix: Correcting some tightening torques and replacing some nuts and bolts.

1 vehicle · built 13 Aug 2019 to 24 Sep 2019

The fuel pipes under the body may have been damaged over time due to a relative movement between these pipes and their surroundings.

Fix: Check the condition of the fuel pipes and replacing them if necessary. New protection will be fitted on all vehicles to prevent this damage in the future.

22,882 vehicles · built 1 May 2016 to 9 Sep 2019

The rear brake hoses may have been damaged over time due to inappropriate movement between these hoses and a clip.

Fix: Check the condition of the rear left-hand and right-hand brake hoses and replacing them if necessary. A new retaining clip is fitted on all vehicles to prevent this relative movement.

21,217 vehicles · built 5 Jan 2016 to 6 Sep 2019

There is a possibility that the rear brake hose may become damaged due to relative movement between the hose and the holding clip.

Fix: Check the condition of the left and right rear brake hoses and replace them if necessary.

4 vehicles · built 13 Aug 2019 to 24 Sep 2019

The tightening and positioning of the seat belt lower bolts may be incorrect.

Fix: This campaign consists of checking and if necessary correcting both the position of the bolt and the tightening torque of all of the lower fixings of the seat belts.

4,485 vehicles · built 17 Dec 2018 to 26 Apr 2019

Possible non-conformity of certain seals in the front wheel arches could lead to water ingress into the passenger compartment.

Fix: Resealing these areas checking for the presence of water in the passenger compartment and replacing certain components in the interior if required.

916 vehicles · built 8 May 2019 to 30 Oct 2019

Certain seals in the front wheel arches may not be correct to specification and may cause water ingress into the passenger compartment

Fix: Resealing these areas checking for the presence of water in the passenger compartment and replacing certain components in the interior if required

3 vehicles · built 15 Oct 2019 to 31 Oct 2019

There is a risk of inadvertent release to the front outer passenger seat belt.

Fix: Modifying the central seat buckle with foam and heat-shrinkable protective tubing

16,828 vehicles · built 16 Apr 2015 to 23 Apr 2019

Possible slackening of the front wishbone ball joint.

Fix: Increasing the tightening torque of the ball joint and adding thread lock if the ball joint threads are found to be rusty or loose the ball joint will be replaced

• TRAVELLER: 10,936 vehicles · built 16 Apr 2015 to 23 Apr 2019
• TRAVELLER: 10,936 vehicles · built 27 Aug 2015 to 23 Nov 2018

Excessive loading of the front suspension could result in the loosening of the front wishbone lower ball joints.

Fix: Increasing the tightening torque of the ball joint and adding thread lock to the ball joint threads if the ball joint threads are found to be rusty the ball joint will be replaced.

2,942 vehicles · built 1 Jan 2015 to 30 Nov 2018

The fixing bolt of the front Suspension wishbone may not be correct to specification.

Fix: Replace the fixing bolts and nuts of the front suspension wishbones.

21 vehicles · built 1 Jul 2016 to 11 Sep 2018

The rear suspension wishbone mountings bolts may not be correct to specification.

Fix: Replacement of the rear suspension wishbone bolts.

326 vehicles · built 5 Oct 2016 to 18 Oct 2018

The air conditioning compressor pulley could break and damage other components.

Fix: Replace the air conditioning compressor pulley and if necessary the protective cover.

2,643 vehicles

The steering rack assembly may not be correct to specification.

Fix: Replace the steering rack assembly and the fixings.

14 vehicles · built 4 Oct 2016 to 8 Oct 2018

The cooling system strategy and the maximum temperature alert could cause the engine to overheat this may cause an oil leak from the sump drain cap. Due to the incorrect operation of the warning system there is no driver alert.

Fix: The remedy involves downloading new engine management software.

841 vehicles · built 10 Mar 2016 to 24 Feb 2018

On the affected vehicles the tightening of a sealing plug on the engine oil gallery may not be correct to specification.This could lead over time to an oil leak which in rare cases could result in oil leaking on to the road.

Fix: The remedy consists of tightening the engine oil gallery sealing plug to the correct torque

47 vehicles · built 30 Apr 2018 to 1 Jun 2018

An engine component may not be to specification which could result in loss of engine performance. This may lead to the engine stalling and potentially causing an engine failure. In very unlikely circumstances the vehicle speed may increase without warning but will stop on its own after a few seconds.

Fix: On affected vehicles carry out a functional diagnostic check of the engine. If necessary replace the engine.

314 vehicles · built 1 Oct 2017 to 30 Nov 2017

The positioning of the starter supply terminal may be incorrect. This may allow it to foul other components and cause a short circuit.

Fix: On affected vehicles check the positioning of the terminal and correct it if necessary.

16 vehicles · built 15 Dec 2015 to 30 Jun 2016

Possible non-compliance of an internal component of the starter control relay could cause damage by overheating. This could cause unintended operation of the starter motor and in extreme instances; there is a risk of fire.

Fix: On affected vehicles check and if necessary replace the relay

84 vehicles · built 25 Jun 2016 to 10 Sep 2016