Alfa Romeo recalls

On affected vehicles due to a production nonconformity there may be contact or a reduced clearance between the fuel Particulate Filter pipe and the pole protection cup of the 48V Belt Starter Generator. Under wet conditions there is a possibility that this insufficient clearance may lead to water infiltration creating an electrical arc which could trigger a thermal event such as overheating. In the worst-case scenario this could result in a risk of fire in the engine compartment.

Fix: Replace the pole protection cup of the 48V Belt Starter Generator. In addition check the distance between the fuel Particulate Filter pipe and the pole protection cup of the 48V Belt Starter Generator. If the distance is less than 10 mm re-position the pipe or replace the pipe if damaged.

1,573 vehicles · built 13 Dec 2023 to 19 Jan 2026

On affected vehicles due to a production nonconformity the wiring harness leading to the headlamp ECU could become damaged by tyre interference with the wheel arch liner which could result in error messages being displayed and a loss of headlamp low beam functionality.

Fix: Inspect wiring harness and wheel arch liner for damage and repair or replace as necessary.

109 vehicles · built 17 Jan 2024 to 3 Dec 2024

On a number of Alfa Romeo Junior vehicles due to a production nonconformity there is a requirement to inspect the brake pedal bracket connection and if necessary perform a rework to eliminate any potential risk of brake pedal disengagement In the event of brake pedal failure the Electronic Park Brake located on the centre console can be applied while driving to bring the vehicle to a controlled stop. Additionally when active the Automatic Emergency Braking system will intervene if it detects an imminent collision.

Fix: The permanent repair involves the Alfa Romeo dealer checking for the presence of the clip confirming correct assembly and reworking it if necessary in accordance with Alfa Romeo reference F53E .

196 vehicles · built 4 Sep 2025 to 29 Oct 2025

On a number of Alfa Romeo Junior vehicles due to a production nonconformity there is a requirement to inspect the brake pedal bracket connection and if necessary perform a rework to eliminate any potential risk of brake pedal disengagement In the event of brake pedal failure the Electronic Park Brake located on the centre console can be applied while driving to bring the vehicle to a controlled stop. Additionally when active the Automatic Emergency Braking system will intervene if it detects an imminent collision.

Fix: The permanent repair involves the Alfa Romeo dealer checking for the presence of the clip confirming correct assembly and reworking it if necessary in accordance with Alfa Romeo reference F53E .

16 vehicles · built 4 Sep 2025 to 29 Oct 2025

Vehicle reliability and your safety are a major concern for Alfa Romeo. On some Alfa Romeo Tonale vehicles the infotainment display may not activate at key-on remaining completely black. This situation is a non-compliance to regulatory requirements.

Fix: The free of charge repair is the Alfa Romeo retailer who will update the vehicle software. Alfa Romeo ref: F50P.

1,683 vehicles · built 29 Sep 2023 to 25 Apr 2025

On affected vehicles there is a risk of a fuel leak at the high-pressure fuel pipe and rail connections which in a worst-case could result in a vehicle fire.

Fix: Check and tighten high-pressure fuel pipe and rail connections.

157 vehicles · built 11 Jul 2024 to 22 Apr 2025

Vehicle reliability and your safety are a major concern for Alfa Romeo. On a number of Alfa Romeo Giulia and Stelvio vehicles there is a requirement to update the software of the Instrument Panel Cluster. This is required to ensure that the acoustic emergency signal sounds after the Lane Keep Assist system is deactivated and ensure it complies with the regulatory requirements.

Fix: The free of charge repair is the Alfa Romeo retailer will update the vehicle software. Alfa Romeo ref: F538.

376 vehicles · built 26 Jan 2024 to 23 Jul 2025

Vehicle reliability and your safety are a major concern for Alfa Romeo. On a number of Alfa Romeo Giulia and Stelvio vehicles there is a requirement to update the software of the Instrument Panel Cluster. This is required to ensure that the acoustic emergency signal sounds after the Lane Keep Assist system is deactivated and ensure it complies with the regulatory requirements.

Fix: The free of charge repair is the Alfa Romeo retailer will update the vehicle software. Alfa Romeo ref: F538.

252 vehicles · built 19 Jan 2024 to 23 Jul 2025

Certain vehicles may have been equipped with an open roof anti-pinch system which does not operate according to specification.

Fix: If required the two motors will be replaced.

9 vehicles · built 15 Nov 2022 to 22 May 2023

Certain vehicles may have been equipped with an open roof anti-pinch system which does not operate according to specification.

Fix: If required the two motors will be replaced.

17 vehicles · built 15 Nov 2022 to 22 May 2023

Affected vehicles may display incorrect tyre size information on the Certificate of Conformity (CoC).

Fix: The CoC must be replaced.

115 vehicles · built 13 Sep 2022 to 8 Jun 2023

Affected vehicles may display incorrect tyre size information on the Certificate of Conformity (CoC).

Fix: The CoC must be replaced.

141 vehicles · built 28 Dec 2022 to 12 Jun 2023

Affected vehicles may have a non-conforming tightening torque applied to the 12V battery recharge cable the two ground cables and the two HV (high voltage) connectors. This could potentially lead to a fire in a worst-case scenario.

Fix: Check for the presence and that the correct torque has been applied to the 12V battery recharge cable the two ground cables and the two high voltage connectors (nut).

318 vehicles · built 2 Sep 2022 to 22 Aug 2023

Affected vehicles may have a non-conforming tightening torque applied to the 12V battery recharge cable the two ground cables and the two HV (high voltage) connectors. This could potentially lead to a fire in a worst-case scenario.

Fix: Check for the presence and that the correct torque has been applied to the 12V battery recharge cable the two ground cables and the two high voltage connectors (nut).

Vehicle count not given · built 2 Sep 2022 to 22 Aug 2023

Affected vehicles equipped with the option BRM (carbon ceramic matrix brakes) may face a braking management issue due to unexpected control unit signals. This may potentially lead to a carbon ceramic disc rupture with a resultant risk of loss or degradation of braking performance.

Fix: Reprogramme the BSM (Braking System Module) with updated Software.

100 vehicles · built 22 Dec 2015 to 23 Nov 2020

Affected vehicles equipped with the option BRM (carbon ceramic matrix brakes) may face a braking management issue due to unexpected control unit signals. This may potentially lead to a carbon ceramic disc rupture with a resultant risk of loss or degradation of braking performance.

Fix: Reprogramme the BSM (Braking System Module) with updated Software.

100 vehicles · built 7 Sep 2017 to 23 Nov 2020

Affected vehicles may have been fitted with a faulty 48-volt battery. This may lead to a loss of the functionality of the battery. This may result in a risk of thermal run away in the case of water infiltration.

Fix: The repair is a check of the PBU valve code and replacement of the 48-volt battery if necessary.

89 vehicles · built 8 Nov 2022 to 28 Mar 2023

Brake lights may remain illuminated when cruise control engaged.�

Fix: Update the software of the body computer module.�

107 vehicles · built 3 Mar 2022 to 24 Sep 2022

The automatic headlight position sensors may not have been calibrated and therefore the function does not comply with the requirements of ECE R48

Fix: Recalibration of the automatic headlight position sensors and alignment of the headlights.

973 vehicles · built 19 Nov 2020 to 11 May 2022

The automatic headlight position sensors may not have been calibrated and therefore the function does not comply with the requirements of ECE R48

Fix: Recalibration of the automatic headlight position sensors and alignment of the headlights.

973 vehicles · built 19 Nov 2020 to 11 May 2022

Due to a production nonconformity there may be the possibility of a fuel leak from the fuel pressure and temperature sensor.

Fix: Replace the front fuel supply pipe and sensor.

157 vehicles · built 15 Sep 2020 to 29 Jun 2021

Due to a production nonconformity there may be the possibility of a fuel leak from the fuel pressure and temperature sensor.

Fix: Replace the front fuel supply pipe and sensor.

157 vehicles · built 15 Sep 2020 to 29 Jun 2021

The vehicle may not comply with ECE Regulation 16 Amendment 07 where all seats must be equipped with a safety belt reminder function with visual and audible indication of seat belt status.

Fix: Conduct a software update to ensure the seat belt indication is available for all occupied seats.

37 vehicles · built 15 Jun 2021 to 16 Jun 2021

The vehicle may not comply with ECE Regulation 16 Amendment 07 where all seats must be equipped with a safety belt reminder function with visual and audible indication of seat belt status.

Fix: Conduct a software update to ensure the seat belt indication is available for all occupied seats.

37 vehicles · built 15 Jun 2021 to 16 Jun 2021

There is a possibility of the rear brake discs having micro-cracks.

Fix: Replace the rear brake discs.

7 vehicles · built 4 Mar 2020 to 20 Aug 2020

There is a possibility of the rear brake discs having micro-cracks.

Fix: Replace the rear brake discs.

7 vehicles · built 4 Mar 2020 to 20 Aug 2020

The seats may not lock in the correct position.

Fix: Check and replace the seat frame if necessary

57 vehicles · built 13 Nov 2018 to 4 Sep 2019

The seats may not lock in the correct position.

Fix: Check and replace the seat frame if necessary

57 vehicles · built 13 Nov 2018 to 4 Sep 2019

The intercooler sleeve may detach.

Fix: The retaining metal band must be replaced with a new component

320 vehicles · built 23 Mar 2018 to 6 Nov 2019

Fuel leakages may occur and fumes may form inside the passenger compartment

Fix: Fit a new plug and seal to the fuel fitter assembly

116 vehicles · built 13 Dec 2017 to 27 Sep 2019

More fuel than actually present in the tank could be displayed on the instrument panel

Fix: Update the software of the control module which governs fuel level management

2,402 vehicles · built 31 Mar 2016 to 30 Aug 2019

More fuel than actually present in the tank could be displayed on the instrument panel

Fix: Update the software of the control module which governs fuel level management

2,402 vehicles · built 31 Mar 2016 to 30 Aug 2019

Undesired acceleration of the vehicle may occur whilst active cruise control is operational.

Fix: Update the software in the brake system module.

493 vehicles · built 31 Mar 2016 to 10 Jun 2019

Undesired acceleration of the vehicle may occur whilst active cruise control is operational.

Fix: Update the software in the brake system module.

493 vehicles · built 31 Mar 2016 to 10 Jun 2019

On some Alfa Romeo Stelvio vehicles due to a potential nonconformity some electric-electronic components may malfunction as a result of water infiltrations and their performance may be compromised. The vehicle may not function as the driver expects it to during use including unintended activation and opening of the rear liftgate door at vehicle speeds up to 3.1 MPH. An unintended activation and opening of the rear liftgate door may result in a loss of unrestrained cargo. Lost cargo may create a road hazard and could cause a following vehicle to crash without prior warning.

Fix: Sealing and/or application of sealants in specific places will ensure full parts conformity is restored.

1,451 vehicles · built 16 Dec 2016 to 13 Apr 2018

The brake/clutch system components may be damaged and system performance may decay as a result of the potential presence of mineral oil in the brake-clutch fluid because the components are not compatible with mineral oil. As a result brake/clutch system performance may deteriorate.

Fix: Replace the components in the brake-clutch system.

11 vehicles · built 14 Nov 2017 to 5 Dec 2017

The brake/clutch system components may be damaged and system performance may decay as a result of the potential presence of mineral oil in the brake-clutch fluid because the components are not compatible with mineral oil. As a result brake/clutch system performance may deteriorate.

Fix: Replace the components in the brake-clutch system.

11 vehicles · built 14 Nov 2017 to 15 Dec 2017

Due to a potential non-conformity in the supplier's production process the front seat belt pretensioner could malfunction and the front seat belt pretensioner may not function as intended in the event of a deployment. The locking mechanism operates independently from the pretensioner therefore locking mechanism functionality is still guaranteed.

Fix: Fit new seat belt assembly to either the driver or passenger front seat or both. The seat belt assembly to be replaced will be determined on the vehicle VIN/ chassis number which will be checked against a list to ensure the correct operation carried out.

352 vehicles · built 29 Sep 2016 to 30 Mar 2017

The wiring loom connected to the transmission oil pump may chafe against a support bracket and damage the wiring.. Damaged wiring may cause loss of drive or adversely affect gear changes.

Fix: Check the wiring for any damage and repair as required. If the wiring is not damaged reposition the wiring.

878 vehicles · built 8 Jun 2010 to 29 May 2015

The tie rod for toe in adjustment could fail at the threads and cause loss of vehicle control. This is due to a nonconformity in production.

Fix: Recall the vehicles that are likely to be affected to replace both rear tie bars.

41 vehicles · built 18 Dec 2007 to 18 Mar 2009

A connector on the brake servo pipe may fail and cause a loss of vacuum assistance necessitating the driver to include additional effort when braking.

Fix: Recall the vehicles that are likely to be affected to fit a new brake servo pipe.

268 vehicles · built 1 Jun 2012 to 30 Sep 2012

The gearbox assembly may fail due to an internal breakage inside the gearbox. This may cause the rear wheels to lock up.

Fix: Replace gearbox

7 vehicles

It has been identified that Pirelli tyre type 215/40 ZR18 89W PZERO NERO annotated MO and F223 may suffer cracking of the sidewall. This can lead to loss of inflation pressure and under certain conditions can have an adverse effect on the safe handling of the vehicle.

Fix: Recalled vehicles will have the subject tyres replaced.

241 vehicles · built 1 Dec 2007 to 31 Jan 2010

It has been identified that Pirelli tyre type 215/40 ZR18 89W PZERO NERO annotated MO and F223 may suffer cracking of the sidewall. This can lead to loss of inflation pressure and under certain conditions can have an adverse effect on the safe handling of the vehicle.

Fix: Recalled vehicles will have the subject tyres replaced.

241 vehicles · built 1 Jul 2007 to 31 Mar 2008

Brake pedal could be stiff to depress requiring more input from the driver to stop as a result of insufficient brake assistance caused by low vacuum at low engine speed while at high altitude immediately after starting.

Fix: Recall the vehicles that are likely to be affected to fit an electric vacuum pump to supplement the engine vacuum system.

100 vehicles · built 1 Jan 2007 to 29 Feb 2008

Brake pedal could be stiff to depress requiring more input from the driver to stop as a result of insufficient brake assistance caused by low vacuum at low engine speed while at high altitude immediately after starting.

Fix: Recall the vehicles that are likely to be affected to fit an electric vacuum pump to supplement the engine vacuum system.

100 vehicles · built 1 Nov 2006 to 30 Nov 2007

It has been identified that the front suspension arm ball joint retaining nuts may not have been tightened to the correct torque. This may result in a metallic noise a vibration through the steering wheel and ultimately a loss of steering control.

Fix: Recalled vehicles will have the ball joint nuts checked for tightness to the correct torque and replaced if the former is not the case.

7 vehicles · built 1 Dec 2007 to 31 May 2008

Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.

Fix: Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.

687 vehicles · built 16 Oct 2007 to 16 Nov 2007

Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.

Fix: Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.

687 vehicles · built 17 Oct 2007 to 19 Nov 2007

Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.

Fix: Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.

687 vehicles · built 20 Nov 2007 to 22 Nov 2007

Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.

Fix: Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.

687 vehicles · built 20 Nov 2007 to 22 Nov 2007

Due to the possibility of a fault in the production process the flexible rubber brake hoses may not have been correctly vulcanised. As a consequence may partially or totally restrict the internal flow of the brake hydraulic fluid. Should this happen a reduction in efficiency during braking would occur.

Fix: Recalled vehicles will have the hoses checked to identify if they are within the affected batch. If this is the case they will be replaced with quality assured items.

687 vehicles · built 16 Oct 2007 to 16 Nov 2007

There is a possibility that the fuel hose from the diesel filter to the high pressure pump may chafe on the fuel filter housing. In time this could result in a fuel leak and the possibility of an engine compartment fire.

Fix: Recalled vehicles will have the routing of the hose checked at which time if the hose is not damaged a new bracket will be fitted to prevent chafing. If the hose is damaged it will be replaced in addition a new bracket will be fitted.

890 vehicles · built 1 Oct 2005 to 31 Aug 2006

There is a possibility that the fuel hose from the diesel filter to the high pressure pump may chafe on the fuel filter housing. In time this could result in a fuel leak and the possibility of an engine compartment fire.

Fix: Recalled vehicles will have the routing of the hose checked at which time if the hose is not damaged a new bracket will be fitted to prevent chafing. If the hose is damaged it will be replaced in addition a new bracket will be fitted.

890 vehicles · built 1 Dec 2005 to 30 Jun 2006

Oil may leak from the Power Take Off Unit which may cause the unit to seize and possible loss of vehicle control.

Fix: Recall the vehicles that are likely to be affected to apply sealant to the core plug and to fit a retaining clip.

610 vehicles · built 1 Nov 2005 to 28 Feb 2007

Oil may leak from the Power Take Off Unit which may cause the unit to seize and possible loss of vehicle control.

Fix: Recall the vehicles that are likely to be affected to apply sealant to the core plug and to fit a retaining clip.

610 vehicles · built 1 Mar 2005 to 28 Feb 2007

Oil may leak from the Power Take Off Unit which may cause the unit to seize and possible loss of vehicle control.

Fix: Recall the vehicles that are likely to be affected to apply sealant to the core plug and to fit a retaining clip.

610 vehicles · built 1 Nov 2005 to 28 Feb 2007

A reflective heat shield may be incorrectly fitted or missing. This could lead to the servo pipe being damaged and the loss of brake servo assistance.

Fix: Recall the vehicles that are likely to be affected to ensure correct fitment of the reflective sheath.

51 vehicles · built 1 Jun 2006 to 31 Aug 2006

It has been identified that certain after market roof cross rails (not supplied by Alfa Romeo) could set up resonance frequencies within the rail that could in time lead to breakage of the longitudinal roof rails.

Fix: Recalled vehicles will be fitted with a new set of longitudinal roof rails.

81 vehicles · built 1 Jul 2005 to 31 Aug 2006

It has been identified that on a small number of vehicles the possibility exists there may be a short circuit situation within the engine additional heater system during the warm up period which could lead to a fire within the engine compartment.

Fix: Recalled vehicles will have the electrical supply to the additional heater modified; in order to avoid the possibility of the short circuit occurring.

1,549 vehicles · built 1 Nov 2001 to 31 Dec 2004

On a number of RHD ALfa Romeo 147 and GT models there is a possibility that the clip which secures the connecting pin between the clutch cylinder and the clutch pedal may become detached resulting in loss of clutch operation.

Fix: Recalled vehicles will be fitted with a redesigned retaining clip.

5,355 vehicles · built 1 Mar 2003 to 31 Oct 2005

On a number of RHD ALfa Romeo 147 and GT models there is a possibility that the clip which secures the connecting pin between the clutch cylinder and the clutch pedal may become detached resulting in loss of clutch operation.

Fix: Recalled vehicles will be fitted with a redesigned retaining clip.

5,355 vehicles · built 1 Sep 2004 to 30 Apr 2006

The Vehicle Dynamic Control (VDC) system does not operate properly when the space saver spare wheel is fitted. This could lead to the VDC warning lamp operating and may lead to reduced braking efficiency if the brakes are vigorously applied.

Fix: Recall the vehicles that are likely to be affected to fit a new VDC electronic control unit that has upgraded software installed.

3,950 vehicles · built 1 Feb 2003 to 30 Nov 2005

The Vehicle Dynamic Control (VDC) system does not operate properly when the space saver spare wheel is fitted. This could lead to the VDC warning lamp operating and may lead to reduced braking efficiency if the brakes are vigorously applied.

Fix: Recall the vehicles that are likely to be affected to fit a new VDC electronic control unit that has upgraded software installed.

3,950 vehicles · built 1 Jun 2004 to 28 Feb 2006

A fuel leak may result due to cracking of the recirculation pipe flange on the fuel tank when the tank is filled to the maximum.

Fix: Recalled vehicles will have the fuel tank inspected for cracks and replaced if necessary.

865 vehicles

A fuel leak may result due to cracking of the recirculation pipe flange on the fuel tank when the tank is filled to the maximum.

Fix: Recalled vehicles will have the fuel tank inspected for cracks and replaced if necessary.

865 vehicles · built 10 May 2004 to 10 Sep 2004

There is a possibility that the high pressure power steering pipe may contact the exhaust downpipe which may result in a risk of fire and loss of power steering assistance.

Fix: Recall affected vehicles check pipe for contact with exhaust and fit extra retaining bracket to power assisted steering pipe.

1,118 vehicles · built 10 Mar 2000 to 11 Mar 2003

There is a possibility that the high pressure power steering pipe may contact the exhaust downpipe which may result in a risk of fire and loss of power steering assistance.

Fix: Recall affected vehicles check pipe for contact with exhaust and fit extra retaining bracket to power assisted steering pipe.

1,118 vehicles · built 10 Mar 2000 to 11 Mar 2003

There is a possibility that the high pressure power steering pipe may contact the exhaust downpipe which may result in a risk of fire and loss of power steering assistance.

Fix: Recall affected vehicles check pipe for contact with exhaust and fit extra retaining bracket to power assisted steering pipe.

1,118 vehicles · built 10 Mar 2000 to 11 Mar 2003

The fitting of an incorrect connector between the brake pipe and the master cylinder may cause the brake pipe to chafe on a power steering pipe support bracket. In the worst case this could result in a fluid leak and a reduction in braking efficiency.

Fix: Replace the connector brake pipe and seals.

29 vehicles · built 1 Mar 2003 to 31 Mar 2003

Possible short circuit and fire risk in engine coolant booster heater wiring circuit during engine warm up period.

Fix: Modify the electrical wiring fit a re-rated protective fuse and install modified mounting bushes.

6 vehicles · built 1 Jan 2002 to 30 Apr 2003

Gradual loosening of the front suspension may result in noise and deterioration of the suspension and handling characteristics.

Fix: Replace the original equipment front suspension reinforcing plates and fasteners with modified components.

213 vehicles · built 1 Jan 2002 to 6 Jun 2003

The metal brake pipe between the master cylinder and the ABS unit may chafe on a cable bracket. A seriously damaged brake pipe will reduce the braking efficiency.

Fix: Check brake pipe condition and clearances. Renew any damaged pipes.

256 vehicles

The fuel delivery pipe from the pump may due to engine movement become strained at its connection to the injector rail. This could result in a fuel leak.

Fix: Fit two additional support clips to the fuel delivery pipe.

73 vehicles

Possible failure of low pressure power steering pipe connection with leakage of fluid and loss of power assistance.

Fix: Recall affected vehicles replace all high and low pressure oil supply and return pipes. Replace oil cooler and refill system with upgraded specification PAS oil.

2,340 vehicles · built 1 Jan 1998 to 31 Mar 2001

There is a risk that under severe operating conditions the engine radiator fan supply cables could overheat with a possible short circuit and fire.

Fix: Recall affected vehicles and check and modify the cables.

122 vehicles · built 1 Jun 1996 to 31 Mar 1998

On some right hand drive 156 vehicles the brake master cylinder supply pipe connectors could develop cracks and leak hydraulic fluid with a possible reduction in braking efficiency of one of the two circuits.

Fix: Recall potentially affected vehicles and replace suspect connectors and two rubber flexible pipes on the brake master cylinder with new upgraded ones.

4,564 vehicles · built 1 Nov 1997 to 31 Oct 1998

On some right hand drive 156 vehicles the brake master cylinder supply pipe connectors could develop cracks and leak hydraulic fluid with a possible reduction in braking efficiency of one of the two circuits.

Fix: Recall potentially affected vehicles and replace suspect connectors and two rubber flexible pipes on the brake master cylinder with new upgraded ones.

4,564 vehicles · built 1 Nov 1997 to 31 Oct 1998

It is possible that a heavy impact on the underside of the vehicle could cause unscheduled activation of the airbag.

Fix: On affected vehicles the air bag control unit will be replaced with a modified component.

1,590 vehicles · built 1 Jan 1996 to 31 Dec 1996

It is possible that a heavy impact on the underside of the vehicle could cause unscheduled activation of the airbag.

Fix: On affected vehicles the air bag control unit will be replaced with a modified component.

1,590 vehicles · built 1 Jan 1996 to 31 Dec 1996

A number of the subject vehicles have been fitted with seat belts manufactured by TRW the attachment systems of which may not remain secure in an accident situation.

Fix: Recall the affected vehicles check the date of production on the seat belt buckles and replace those within the critical batch.

12 vehicles

A number of the subject vehicles have been fitted with seat belts manufactured by TRW the attachment systems of which may not remain secure in an accident situation.

Fix: Recall the affected vehicles check the date of production on the seat belt buckles and replace those within the critical batch.

12 vehicles

When fully loaded the rear brake hoses may contact the anti roll-bar upper attachments and a plastic shield. This could damage the hoses and cause fluid loss with a consequent reduction in braking efficiency.

Fix: Recall the affected vehicles for rerouting of the rear brake hoses. Any hose found to be damaged will be replaced.

12 vehicles

When fully loaded the rear brake hoses may contact the anti roll-bar upper attachments and a plastic shield. This could damage the hoses and cause fluid loss with a consequent reduction in braking efficiency.

Fix: Recall the affected vehicles for rerouting of the rear brake hoses. Any hose found to be damaged will be replaced.

12 vehicles

Interference could occur between the gearbox wiring harness and the cover for the brake pedal cross shaft located in the front foot well. In time this could damage the harness and cause a short circuit with a consequent risk of fire.

Fix: Recall the affected vehicles and protect the wiring harness by fitting a length of protective strip to the lower edge of the cross shaft cover.

161 vehicles · built 1 Sep 1992 to 31 Jan 1995

On some cars a hose longer than specified could have been erroneously fitted with consequent possible interference with the engine. Such interference could in the long run cause the perforation of the hose oil leakage and a potential risk of fire.

Fix: Recall the affected vehicles and a check on the length of the hose. In cases where the hose is found to be too long it will be shortened to the right length or if damaged will be replaced.

195 vehicles · built 1 Jun 1992 to 30 Jun 1994

On a specific batch of rear wheel bearings the outer bearing race may break up during certain operating conditions leading to failure of the bearing and hub detachment.

Fix: Recall the affected vehicles for inspection and replacement of the affected bearings.

325 vehicles · built 1 Jan 1992 to 31 Dec 1993