Toyota Proace Verso recalls

For certain vehicles there is an error in the specific software calibrations of the Engine Control Unit. In certain cases this condition may result in a delayed activation of the malfunction indicator (MIL) allowing the vehicle to operate with tailpipe emissions exceeding limits before the MIL is triggered

Fix: Update to the software calibration of the Engine electronic control unit (ECU).

407 vehicles · built 6 Dec 2022 to 13 Feb 2025

Affected vehicles may have excessive corrosion on the front suspension arm bolt due to the design in combination with environmental factors. As a result the bolt may fail which may affect controllability of the vehicle

Fix: Replacement of the front suspension arm bolts and bush

2,861 vehicles · built 3 Mar 2016 to 8 Jul 2022

For affected vehicles there is an issue where the Malfunction Indicator Lamp (MIL) may not activate in case of a fault in the Selective Catalytic Reduction (SCR) system and/or Diesel Particulate Filter (DPF).

Fix: Carry out an update to the software of the Engine Electronic Control Unit

1,145 vehicles · built 7 Jul 2017 to 16 Dec 2021

For affected vehicles equipped with the 1.5L diesel engine there is a possibility that premature wear of the camshaft chain may occur. Premature wear occurs primarily due to chain design which causes excessive tension in high engine speed and high engine load conditions which can lead to abnormal noise and risk of breakage of the chain.

Fix: Inspection of the camshaft chain replace where required and update the engine ECU software

706 vehicles · built 9 Jul 2018 to 1 Feb 2023

On affected vehicles the front and/or rear seat fixing points may have a reduced strength due to the thread of the fixing nut not being of the correct specification.

Fix: The fixings will be reworked with new nuts and bolts fitted.

202 vehicles · built 29 Aug 2024 to 1 Oct 2024

On affected vehicles incorrect specification rear coil springs may have been installed.

Fix: Carry out check and replace coil springs if required.

5 vehicles · built 2 Apr 2024 to 29 Jun 2024

When the data is read out from the vehicle ECU an incorrect IUPR (In-Use Performance Ratio) value is shown. This does not comply with regulations however there is no impact on safety or vehicles' exhaust emissions

Fix: Reprogram the Engine Control Unit (ECU) with updated software and calibration.

1,177 vehicles · built 1 Jun 2021 to 15 Jun 2022