BYD recalls

During anti-corrosion treatment the steering box mounting surfaces were not adequately masked. As a result anti-corrosion paint contaminated the mating surfaces leading to insufficient metal-to-metal contact when the steering box was installed. This can cause the steering box to loosen over time potentially affecting steering control.

Fix: Removed anti corrosion paint from mating surfaces.

489 vehicles · built 23 Jul 2024 to 28 Dec 2025

During anti-corrosion treatment the steering box mounting surfaces were not adequately masked. As a result anti-corrosion paint contaminated the mating surfaces leading to insufficient metal-to-metal contact when the steering box was installed. This can cause the steering box to loosen over time potentially affecting steering control.

Fix: Removed anti corrosion paint from mating surfaces.

5 vehicles · built 1 Feb 2024 to 28 Dec 2024

On affected vehicles the high voltage emergency shutdown can be overridden by intelligent charging when low voltage batteries state of charge drops below a specific level.

Fix: Update drive module software and dashboard display software.

18 vehicles · built 1 Mar 2016 to 31 Aug 2016

On affected vehicles the high voltage emergency shutdown can be overridden by intelligent charging when low voltage batteries state of charge drops below a specific level.

Fix: Update drive module software and dashboard display software.

Vehicle count not given · built 1 Mar 2016 to 31 Aug 2016

On affected vehicles the high voltage emergency shutdown can be overridden by intelligent charging when low voltage batteries state of charge drops below a specific level.

Fix: Update drive module software and dashboard display software.

Vehicle count not given · built 1 Mar 2016 to 31 Aug 2016

On affected vehicles the high voltage emergency shutdown can be overridden by intelligent charging when low voltage batteries state of charge drops below a specific level.

Fix: Update drive module software and dashboard display software.

945 vehicles · built 1 Aug 2016 to 31 May 2024

On affected vehicles there is a potential issue relating to the Hispacold HVAC system which may result in a fire when a vehicle is left unattended

Fix: Service Bulletin Reference 966 Rev 3 must be adhered to. A permanent solution is being investigated.

1,065 vehicles · built 3 May 2019 to 6 Feb 2024

On affected vehicles there is a potential issue relating to the Hispacold HVAC system which may result in a fire when a vehicle is left unattended

Fix: Service Bulletin Reference 966 Rev 3 must be adhered to. A permanent solution is being investigated.

1,065 vehicles · built 3 May 2019 to 6 Feb 2024

On affected vehicles incorrect tempering of the anti-roll bar causes failure due to metal fatigue.

Fix: Check and replace the front anti-roll bar.

965 vehicles · built 1 Dec 2020 to 1 May 2023

The HVAC DCAB protection box may become loose resulting in damage to wiring and overheating /electrical short.

Fix: Check the fixings for presence and security. Replace the HVAC DCAB protection box if necessary.

220 vehicles · built 1 Mar 2020 to 31 Jul 2022

The driver can adjust the steering wheel position while the vehicle is in motion. The vehicle may become difficult to control if the driver was to adjust the steering position while driving.

Fix: Recall the vehicles that are likely to be affected and fit an Interlock device so adjustment can only be made while the handbrake is applied.

65 vehicles · built 1 Aug 2015 to 30 Dec 2016

The driver can adjust the steering wheel position while the vehicle is in motion. The vehicle may become difficult to control if the driver was to adjust the steering position while driving.

Fix: Recall the vehicles that are likely to be affected and fit an Interlock device so adjustment can only be made while the handbrake is applied.

65 vehicles · built 1 Aug 2015 to 30 Dec 2016

The driver can adjust the steering wheel position while the vehicle is in motion. The vehicle may become difficult to control if the driver was to adjust the steering position while driving.

Fix: Recall the vehicles that are likely to be affected and fit an Interlock device so adjustment can only be made while the handbrake is applied.

65 vehicles · built 1 Aug 2015 to 30 Dec 2016

It has been identified that the material used to manufacturer the Pitman arm from is not to the correct specification. This can cause wear of the arm and lead to possible detachment of the drag link which could lead to loss of control of the vehicle.

Fix: Recall all vehicles for the replacement of the pitman arm with a new quality enhanced item.

5 vehicles · built 1 Aug 2015 to 30 Dec 2015